Z Grills Wood pellet grill and Camp Chef pg24 are mostly different in a lack of an ash removal system or various interesting features. No ash removal system means having to manually clean the grill of ash. It is not a difficult task as the access to the fire pot is easy, but a vacuum cleaner will be necessary here in order to remove the ash fast and easily.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.

Z Grills Wood pellet grill and Camp Chef pg24 are mostly different in a lack of an ash removal system or various interesting features. No ash removal system means having to manually clean the grill of ash. It is not a difficult task as the access to the fire pot is easy, but a vacuum cleaner will be necessary here in order to remove the ash fast and easily.


Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
Make dinner for the family with the Camp Chef 12-Quart Grand Canyon Cast Iron Dutch Oven. This unequaled cookware is designed with... a beautiful scene of the Grand Canyon featured on the outside to commemorate 100 years of the national park. The Camp Chef cookware is not only attractive; it is useful as well. The deep-dish lid doubles as a skillet or serving trivet, and the pot comes preseasoned so it is ready to use. The Camp Chef Dutch oven includes a lift tool so you can carry the pot from the stove to the table with ease, and a thermometer channel allows you to check the temperature without lifting the lid, so the heat stays inside. This cookware is just what you need for camping trips to cook for the whole family. It is large enough to feed everyone, and it is sturdy for cooking over alternative heat sources. The unique lid that doubles as a skillet helps save room when you pack up for a weekend camping. read more
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.

This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!


If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
Hey Bill! I think you’d be very happy with a Yoder pellet smoker. From a product and manufacturing standpoint, they’re great pellet smokers. If you’re looking at spending $1,700 and can perhaps go a little higher, you can then consider either a MAK grill or a Memphis Grill Pro Series. These are fantastic pieces of equipment. They are insulated at the point where the lid touches the body at closing, and provide superior convection cooking. Anytime you feel you want some extra smoke, you can always throw in an Amazn Pellet Tube or use a Mojo Cube. These will amp up your smoke profile in a manner you can predict and keep under control. I would NOT recommend adding anything foreign to your burn pot ever. Just keep things from the main pellet smoker function working as per the manufacturer’s design.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
The Camp Chef Camp Table is the perfect companion to any table top stove or dutch oven. The camp table will hold two 14 inch dutch... ovens and provides extra preparation and serving space to keep your food up off the ground. Works great with the Mountain Series stoves from Camp Chef and is a great accessory piece to your free standing stove. Side shelves* (Model LS60P) can be added for even more space. read more
Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
Yeah it seems like no one is providing any input on it…I was interested in having them review it and do a direct comparison to some of these other grills. I made the mistake of getting a Myron Mixon pitmaster Q3 at sears. It turned out to be a waste of money and the slight humidity I had caused the pellets to burst and seize up the Auger. Anyway I had narrowed my search down to a rec tech or silverback but none of the reviewers seems to be giving it any attention.
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
114 deals were found for Pit Boss Pellet Grill. Deals are available from 7 stores and 4 brands. An additional discount is available for 24 items. Last updated on December 20, 2018. Scanning all available deals for Pit Boss Pellet Grill shows that the average price across all deals is $332.75. The lowest price is $1.99 from amazon while the highest price is $1,299.99 from Kotula's. The average discount we found across all deals is 18.92%, the largest discount is 49.54% for the product Pit Boss 700FB Classic Pellet Grill Cover from Walmart.com. New products prices vary between $1.99 and $1,299.99. Free shipping is offered across 6 stores - amazon, ebay, Hayneedle, Kotula's, Walmart.com, Wayfair.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.

I have the larger Traeger smoker and have really liked it but not from the start. I had issues with the heating unit but the Traeger help people managed to get my “mechanical blondness” through this and all is well. The assistance center people at Traeger weres super supportive so I’m a loyal fan today. One thing I suggested to Traeger, and all who have a Traeger smoker, is to make the grill surface in two parts so it fits into a dishwasher. I cut my grill in half allowing it to fit in my dishwasher. Easy peasy to clean now!
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
The Camp Chef Lumberjack Over the Fire Grill is a simple solution for cooking while on a camping trip. Simply place the Camp Chef ...Grill over the campfire coals and get to cooking. The durable plated steel body will stand up to the occasional knocks and bumps that happen outdoors. Foldable legs ensure that this camping grill will pack up quickly and transport easily. The large cooking surface of this Over the Fire Camping Grill is large enough to accommodate almost any camping cooking equipment you might want to use. The steel mesh top on this grill is well-suited for grilling a variety of foods, including steak and vegetables. Whether you are sitting down for a meal after a long day on the trail or you have been out on the lake, the Camp Chef Lumberjack Over The Fire Grill is an smart choice for your campfire grilling needs. read more

So, I say go for the best pellet grill you can get within your budget. I reviewed the little GMG Davy Crockett pellet grill recently and was impressed. At just under $400, it’s a good option. That said, I would like to see them put the unit on fold down legs with casters or some other option to make it easier to move around. You’ll see what I mean in the post. Hope this helps.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
So what about the question of blends versus 100% pure species pellets?  Should you avoid blends?  Should you only use 100% pure?   That is a web to unweave and depends greatly on what you are cooking as to the correct answer.  Through our testing we found many blends to work very well.  We liked them so much that we incorporated them into what we offer.  Not all blends are created equal though and the amount of hardwood versus flavor wood varies widely across brands.  We also found that some 100% pure pellets such as cherry and apple had harder times reaching higher grilling temperatures and lacked the harder core flavor punch of hickory or mesquite.  Coming from the world of stick burners many new pellet grill owners assume that going 100% cherry or apple is going to work for them since that is what they have grown accustomed to.  At the end of the day, they end up moving to a pellet with a deeper flavor like hickory or mesquite to get the results they are used to.
Second, you’ll have to figure out what BBQ pellets you want to use. There are many different brands, blends, and mixes to choose from, and you’ll likely want to do some side by side testing to see what you like best on what meats. My very good friend and BBQ buddy Shane Draper (ofDraper’s BBQ Rubs and Sauces) really likes to make his own blends — using different woods in different proportions depending on what he’s cooking.
The Woodwind is a Pellet Grill for the connoisseur. Along with a high price tag come all sorts of fancy extras, from a specially constructed 'sear box' to a lever-operated cleaning system for removing wood ash. It's roomy too, with over 500 square inches of cooking space so whether you're cooking for one or smoking several racks of ribs at the same time, the Woodwind will get the job done.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.


After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
We ended up going with the Memphis Pro. We were fortunate enough to be able to see all of the manufacturers and models I was most interested in, at Sam’s NW BBQ. (Yoder, MAK, Fast Eddy, GMG’s, a few others, and then, the one we ended up with, Memphis.) Sam took a good amount of time, providing us fantastic information about each model. We ended up with the Memphis Pro for the following reasons: 1) The construction, mainly the double-walled construction; 2) the preciseness of temperature, and being able to hold the temperature (due to reason #1); 3) the extreme ease of changing from smoking to grilling without a lot of effort or reconfiguration; 4) the double hoppers; 5) and another BIGGIE, the fact that grilled or baked foods taste like that, and not like smoked cookies, bread, pizza, etc.
Rest the cast iron press on your skillet or griddle to warm. Use the press on top of bacon to speed cooking times as it cooks from... both sides. Use as a hot press with your favorite sandwiches to turn them into a hot and melty favorite. The grill lines from the ridged bottom will sear the sandwich for a tasty presentation. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.

Multi-position and digital controllers ( LED display ) - a much better solution, but it does have its flaws. First a multi-position controller, then a digital controller that allows to set the temperature at intervals of +/- 25 degrees F. It’s a controller that also has poor responses to weather. A great advantage of a digital controller is that it allowed to implement other innovative solutions. It helped introduce such technologies as alerts, timer or better meat control.
Pay attention as well to what temperatures your grill can heat up to. Most of pellet grills can maintain a temperature within 160-500 degrees F ( with much more expensive models is even  600 degrees F ). Why am I mentioning that? Because you have to think about what is the most popular grilling style for you. It will influence whether your pellet smoker will be a good choice for you.

Now we come to the part no one likes and that’s cleaning. This smoker won’t clean itself but it does make the process a lot easier. PG24 by Camp Chef Pellet Grill is created in a way that gives you easier access to the fire pot making cleaning out the ash effortless. It also has trap door that allows you to clean the unit without scouring through grease and ash. Anyone who has ever had to clean a smoker grill knows how time-consuming and enormous the task can be. This trap door is only present in expensive units, but you’ll be glad you paid a little more when cleaning becomes effortless. You could also buy the other version that could come with cover (which is $50 more expensive) to make sure the smoker is in the best condition at all times.


Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.

The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
At the end of the day, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet smokers use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
I'm using a ThermoWorks "Smoke" thermometer to send smoker temp info while I'm busy doing other things. So much easier to set it and not having to worry about it compared to grilling over charcoal (although I still like to do that for high temp California "BBQ"). Just come back when it's close to being done to give a quick visual check compared to the probe temperature. May consider adding the sear box in the future.
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.

But as said, there are a few things we don’t like; it’s relatively small, doesn’t have a lot cooking space, and the design feels cramped. At the same time, it’s still relatively heavy at 140 lbs. For the same price, you could choose the Z-Grills Master 700D, which packs almost 25% more surface area on the rack. That doesn’t seem like much but is a significant amount of room.  Or you could just spring for the Traeger Pro 22. There have also been reports of poor quality control, and that the temperature control is very inconsistent, often swinging up and down nearly 30 or 40 degrees.

I had heard about Traeger from a friend who was at a conference where the catering was done on one of the commercial units. He had said the food the it made was mind blowing, and on a late night impulse buy I decided to purchase this from Amazon - as an open box/scratch and dent for about $800.There are some less expensive grills available, I have never owned them so I can't comment on them. i started to get a little buyers remorse with all the negative reviews this grill had received, but decided to give it a fair shot. It arrived quickly not by UPS but from trucking company. Despite being listed as damaged box/open box it was well packaged no damage. Assembly took 30 min by just me, assembly tools were included. Stood it up off the floor and filled the hopper with mesquite and followed break in procedure listed to cook off any manufacturing oil etc. Let it cool retired it once more to make sure it was seasoned let it cool again and was ready to go. I purchased an IGrill wireless thermometer to go with it which I would recommend also. I signed up to the Traeger recipe sight and they send a recipe every few days, and you can browse the website for some inspiration. Since I have owned this I have gone thru about 3 bags of pellets including alder mesquite and hickory. I have grilled Trout ( the smoked trout dip list on the website was amazing) as well as trout fillets, Salmon, Haddock, Ribs, Brisket, Pulled Pork x 3 and 2 prime ribs and 2 loafs of bread Jerkey ( smoking now) butternut squash etc etc . All the food I can only say is mind-blowing - enough so that 4 of my friends have purchased the smaller Traeger's for themselves. It has all been incredibly easy - just season, set the temp put the food on and the temp probes in and forget it- the wireless I grill continually upgrades my phone so I can keep working inside and not have to worry. It has never failed to light, caught on fire, overheated or preformed to anything other perfection for me. I can't speak for all the other negative reviews but I have had nothing but success with this, the Weber propane I own hasn't been touched is just taking up space it can't compare to this thing. Its a big purchase at close to 1k but is incredibly versatile I can't speak about customer service response because I haven't needed them, but if you are concerned I would call the headquarters and see how hard it is to get someone on the phone. The Temp probe is off by a few degrees compared to my Igrill reading but the grill has no trouble maintaining a narrow temp window if you keep the lid closed and don't F%$k with it . Most important it has bought back some passion to cooking, and made me want to try new things which is priceless.
Grill will not maintain temperature with temperature set at 275 the grill temperature will range from 200 to 320 and this continues throughout the entire time it takes to cook the food. Customer service is giving me the runaround and no resolution has been made. I have been on the phone two times and they say that the pellets are not dropping into the screw. I have done everything they have asked me to do and still have same issue.
I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.
It’s got built in manual controls, but there’s also the option to download an app to your phone so you can control your smoker through your wifi! Honestly, this really impressed me, and I don’t know why other manufacturers aren’t all over this. Apparently there’s a cloud based app coming out soon so you can control your grill anywhere you can get internet, so you could be sitting at your kids football game whilst checking the status of your post-victory feast! The controls are also fully programmable, so you could for example set it to smoke for 5 hours and then cook for 2, finishing just as you pull up onto your drive.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.

Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
Third, we’re experienced: We have burnt our foods and fingers; and while we were at it, we learned from our mistakes. In doing so, we’ve managed to become the best and mastered the art to perfection. So, we went through the same learning curves that you did or might do. So, we’re aware of the things that matter and we’re going to impart that knowledge with you, so that you don’t make the same mistakes as us.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.

One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
I haven’t posted here before, but have been reading and finding a lot of good information on this site. I am in the market for a pellet grill so have been researching some of them listed on this site. Out of Yoder, Green Mountain, Memphis and MAK I really like price, features and looks of the Yoder YS640. I was wondering if anyone has used Louisianna pellet grills? For example, the CS680? I don’t see it mentioned much on bbq blog sites so not sure if it is a good brand. Thanks for any advice.

So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
×