Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)
When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.
Apart from the replacement parts for a pellet smoker, there are also certain accessories that one can use to increase the range of its usefulness as well as improve its performance. A user can attach a griddle attachment to a pellet grill to use it as a flat top griddle, or use a hopper extender to increase the pellet hopper capacity; there is an attachment for every purpose to suit all of your needs. Let’s take a look at the types of accessories commonly found:
Regarding your question about a decrease in smoke flavor when using the pellet grill / smoker, I do believe you will experience a little bit of a drop off. This said, many people find the flavor from pellet grills / movers to be adequate. If you require a stronger smoke profile, you can always use one of the tube smokers that sits inside of the cooking chamber.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
For me, grilling is a way to communicate to the people in my life that I love them and to easily involve others in my passions and hobbies. So, to be able to guarantee perfection in every meal isn’t just about eating well, it’s about reliably being able to put my best foot forward with these people who matter. And the remarkable thing about the Traeger is that you can expect to be able to do the same from the very first time you use it.
When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually.
Through the years, pellet smokers have gained popularity. The fact that they give you the convenience of being able to hold a barbecue from the comfort of your home is what makes them ideal. However, not all of them will match up to the needs that you have and this is why I put together this guide with reviews. Following this guide, you should be in a position to make a comprehensive decision on the specific model to buy.
You can whip up a delicious meal in no time with the Camp Chef Dutch Oven Stand. This cooking stand is especially convenient for t...hose who want to do tabletop cooking, as the stand gets your oven to just the right level so that you can make your food with ease. The heavy-duty steel platform of this Dutch stand ensures durability. This stand is designed to hold a 14 inch Dutch oven and should be placed only on a non-combustible surface. read more
4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
The Camp Chef Italia Pizza has all the tools you will need to make you feel like a professional pizza chef. The artisan pizza kit ...includes two pizza peels to move your pizza from the counter to the oven and vice versus. Your pizza will slide right into the pizza oven or stone with ease just like a true artisan. Made of eco-friendly, renewable bamboo. Do not wash in the dishwasher. Dimensions: 11.75 Inch x 19.25 Inch x 0.35 Inch. Weight: 1.3 lbs. read more
When it comes to spending your own hard-earned money on a new wood pellet grill, you want to invest in a product that is going to last you for a while. There are many differences between purchasing a cheap wood pellet grill and a pellet grill that is built with quality materials. Even though the cheaper grill may be easier on your wallet in the short run, the long-term costs will quickly outweigh the initial savings. So, if you’re thinking of buying a cheap pellet grill, continue reading to learn about the true costs that could be associated with your decision.
Main products of our company :electric, home,toy,clother ,etc. Since its foundation ,the company keeps living up to the belief of ...:"honest selling ,best quality ,people-orientation and benefits to customers. "We are doing everything to offer our customers with best services and best products .We promise that we'll be responsible all the way to the end once our services begin This 4-quart Classic-style 10" Dutch features a beautiful white tail deer etching on the lid, three legs, a handled lid and bale. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood. Seasoned and ready to cook.Total Weight = 13 lbs.Depth: 3 1/4"Capacity: 4 QT.ID = 10"OD = 10.25"Model No: SDO10UPC Code: 033246208060 If you have any further questions, please feel free to contact us. We look forward to serving you in the future. read more

Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.
The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
Set it and forget it. It does not require you to stay while the food is being cooked as you can set a timer and temperature so you can do other things, like prepare the side dishes or drink beer with friends while the grill is doing its job. Most pellet grills use electronic controls to regulate the grilling according to your preferences. You have a choice to choose the level of smoke aside from choosing your desired temperature.
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.

Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.

As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.
As the last criteria that we took into consideration, we have shared this a couple of times but we really wanted to focus on variety. We not only wanted to share some of the best tops of the line brands in the industry but we also wanted to share brands that may be unknown but offer excellent craftsmanship and material design. For instance, some of the grills we have shared are perfectly designed for everyday use, while some are designed for large events and parties.
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.

The Camp Chef Lumberjack Over the Fire Grill is a simple solution for cooking while on a camping trip. Simply place the Camp Chef ...Grill over the campfire coals and get to cooking. The durable plated steel body will stand up to the occasional knocks and bumps that happen outdoors. Foldable legs ensure that this camping grill will pack up quickly and transport easily. The large cooking surface of this Over the Fire Camping Grill is large enough to accommodate almost any camping cooking equipment you might want to use. The steel mesh top on this grill is well-suited for grilling a variety of foods, including steak and vegetables. Whether you are sitting down for a meal after a long day on the trail or you have been out on the lake, the Camp Chef Lumberjack Over The Fire Grill is an smart choice for your campfire grilling needs. read more

So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
The construction and the elements - REC TEC  Pellet grill are an investment for years, safe from corroding. Most of competitive  grills look pretty on the outside and the manufacturers claim they are made of stainless steel. The truth is, only the outside part of the grill is stainless. The steel on the inside is different, and major parts are made of materials of poorer quality.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.

One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills 

BBQ fan – If you’re a more demanding person, grill a lot of different meat using different methods. Then pellet grill will work great for you. Especially when it comes to smoking meat for many hours, all you have to do is set the temperature and do whatever you please in the meantime. You can leave it for the entire day with no worries and after a specified time expect very good results, as a pellet smoker is very good at maintaining desired temperature. To put it shortly, a pellet grill will make it easier for you to prepare a top quality meat at home.
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®. By submitting this rebate form, you agree to resolve any disputes related to rebate redemption by binding arbitration and you waive any right to file or participate in a class action. Terms and conditions available at www.rebateinternational.com®
I bought the Pit Boss 440 Deluxe & cooked a pork butt. Set it on Smoke (P4) all was well for 2 hours then temperature ran away to over 615 degrees. Ruined that piece of meat. Called customer service & they talked at me instead of listening to me. Tried another pork butt set on 225 degrees temp once again ran away after an hour. Wrote an email to customer service with a response that they were sorry I was having trouble. Tried again today with the same result so sent another email with pictures of settings & indicated temperatures. Guess I'll have to finish this pork butt in the oven & go buy a Treagar Pellet Grill. If Pit Boss corrects this I'll update this review!

The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
×