Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles. 

Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
The fight for building the cheapest pellet smoker with decent quality is pretty intense. Unfortunately, a cheaper pellet grill often leads to lower quality construction. The Camp Chef SmokePro DLX is more expensive then the Pitboss 71700fb, and in our opinion the Pitboss is the better pellet smoker. It isn’t a bad unit; the controller of this smoker even includes a meat probe which typically comes only with the more expensive units. However, it does have one flaw – the lid.
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.
PID Controller – one of the best controllers. Precisely maintains the temperature you set at intervals of +/- 5 degrees. Perfect when it comes to long and slow meat smoking at low temperatures. You can leave such a pellet grill for the entire day without worries and forget about it. When coming back after many hours, you’re sure that your meat has been cooked at the fixed temperature that you set.
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.

The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!

One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.
So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills

Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.


First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
Be that as it may, if your concern mainly lies on something that can be carried on a truck to an open-air grilling party or to a friend’s place, it’s positively a decent proposal. Aside from portability, it also gives you a cooking adaptability as you can grill, prepare, smoke, grill and braises with no bothers. The grill highlights full-size functionalities in a convenient bundle, henceforth a decent decision for anybody searching for versatile decision.

Regarding your question about a decrease in smoke flavor when using the pellet grill / smoker, I do believe you will experience a little bit of a drop off. This said, many people find the flavor from pellet grills / movers to be adequate. If you require a stronger smoke profile, you can always use one of the tube smokers that sits inside of the cooking chamber.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
Hello.. You recommended a couple weeks ago to go with a GMG grill and that is the one I’m going with. I’m just a little torn between the DB and JB. They are only $150 apart but I’m not sure if the bigger size is worth the money when I can spend that on a cover and some pellets. Do you think the bigger size is worth it for a back yard smoker with the occasional party? I know people say bigger is better but I went bigger with my previous barrel smoker and it was much harder to keep an even temp with the bigger size. I would have went smaller given the chance. Thanks for any input!

I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.

Rec Tec Wood Pellet Grill boasts a cooking area of over 1000 sq. inches. However, that area is calculated from its optional cooking shelf. Without it, the cooking area is roughly around 700 sq. feet. This removable shelf can allow you to increase your cooking area if you’re trying to cook patties, steaks, chicken pieces and items as such; or they can be removed for granting a greater volume of space for smoking brisket or whole turkeys.


Accurate, powerful, with a lot of options, good build quality and a nice set of features, all at an excellent price, the Camp Chef PG64 is our best overall pellet smoker. Of course, the RecTec still offers more options, but it’s more expensive, so if you want the absolute most for your money, without breaking the bank, you’re going to want to look closely at this.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.
Camp Chef SPG-90B 30,000-BTU 3-Burner Big Gas Grill:3 burners30,000-BTU burnersAppliance-style control knobsIndependent leveling l...egsCamp Chef gas grill has a removable grilling attachmentConvenient carrying handles on the barbecueGas grill hose and regulatorSide shelf and a hinged-lid barbecue box that covers 2 burnersCast-iron, pre-seasoned grate to sear in flavorMassive grilling surface30,000-BTU gas grill is a versatile outdoor kitchenAllows you to barbecue and grill meats quicklyBurners produce three times the heat of a normal kitchen stoveUse for tailgating and other outdoor eventsAllows you to switch out cooking accessories to meet your needs16" surfaceUse the 3 stove burners in any pot, pan or skillet configuration read more
I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
Cleaning other types of smokers typically includes scooping ash from the burners and removing burnt remains from the racks. Traeger turns this messy process into a very simple one. The smoker burns pellets so efficiently that there is almost no ash left behind. Since there is no direct flame, the cooking grates will not get sticky and caked with excessive amounts of burnt, juicy meat. In order to clean the racks, all you have to do is brush them quickly and then wipe them with a paper towel.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.

Food, especially meat, tastes much better when smoked. If you want to take up smoking food but you’re worried that it might be too complicated there is one simple solution for you – get yourself a pellet smoker. Pellet smokers, also known as pellet grills, have started selling like crazy as people begin to realize they are incredibly easy to use. You may not get the street cred from traditional pit masters with your pellet grill and smoking skills, but you will be able to produce excellent barbecue effortlessly. Wood pellet grills give you smokey, juicy, and tender meat that’s perfectly cooked without the hassle of babysitting your smoker.
Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)

I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
There have been some claims pellet grills are a safer barbecuing option.The claim is that pellet grillers by design do not allow as much of this potentially dangerous smoke to come into contact with the food. The fact that pellet grills don’t reach the same temperatures that other grillers do has also given rise to the idea that it is a safer barbecuing option.

Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.

×