Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.

There’s so much about this grill to love, but one aspect that gets RAVE reviews is the customer service. Rec Tec has pretty much the best customer service in the industry. First off, there’s a 6 year warranty, meaning, they expect their product to perform. But in the unlikely case that you have issues, their customer service is incredibly fast to respond, is available even on the weekends, and believe it or not, the owners even provide their cell phone numbers so they can help you through a problem when you’re stuck. Incredible!
So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!

Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
Temperature: Most of all, you have to pay attention to whether your pellet grill maintains a chosen temperature. People buy a pellet smoker because it makes it possible to smoke meat for long at fixed low temperatures. Very convenient and simple, and a grill that always maintains a selected temperature guarantees that the meat will be perfectly cooked.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.
You aren’t limited to basic barbecuing. For us, what really stood out was its ability to deliver pro chef-level cooking even at home. This smoker lets you explore all there is about cooking, letting you braise, grill, smoke, bake, roast, braise and BBQ all kinds of food. Using only the best and the purest hardwood pellets, you’re sure to have the juiciest and tastiest meats and vegetables every time you host your outdoor parties. If you think you have to give up quality because of the quantity of foods it can cook, that’s not the case. Quality is maintained whatever it is you’re cooking.

Warranties are an important part of purchasing a new pellet grill because it assures that the manufacturer stands behind the build quality of the product.  It’s just like buying a new car – you want a warranty that will cover the costs of a repair if something happens to go wrong after buying. Depending on the pellet grill that you buy, there is a wide range of different warranties that are included. Cheap pellet grills will sometimes include a short-term, limited warranty that covers next to nothing. A quality manufacturer will be willing to add some years onto their warranties and cover all the components you’d expect (for example, Grilla Grills offers a 4-year warranty with VERY little fine print on the popular Silverbac model). So, if your cheap grill magically makes it past its warranty date unscathed and then something happens to it, you will be left paying out of pocket for the costs of fixing it or replacing parts. By comparison, pellet grills that have a lifetime or long-term warranty will give you more peace of mind rather than worrying about how you will pay for the next component that malfunctions or breaks suddenly.

Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.


GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.

I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
The simplicity with which you can use this product is outstanding. From the time that you put it together to the time you smoke meat to the time you clean it, the entire process is extremely simple. It has a power failure restart and a dump tray that can easily be cleaned out. The cooking surface is so large that it is possible to smoke two turkeys at once.
Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.

Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
As time passed, a thermostat was added to the equation, and the production BBQ smokers fueled by pellets working in “set it and forget it” fashion was in full force. From this point, several manufacturers of pellet grills began to pop up, with a few key names like Yoder Smokers, Mak Grills, Green Mountain Grills, and Fast Eddy’s Cookshack grills being among the most notable.
Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
With the Yoder YS 640 you won’t have to worry about scooping the ashes anymore. This pellet smoker burns the pellets so efficiently that there will be almost nothing left to clean. All you will have to do is empty the ash tray every now and then and wipe down the grates. You can spray the grates with PAM prior to use which makes clean up even easier.
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
Minor problems (Product): 1. Main grill rack does not fit snugly, leaving the rack to half almost a half an inch in all directions to move. (not so much a problem when cooking but it does move) 2. Wind is a major factor making it difficult for this to get up to heat and stay there. 3. It rarely comes to the temperature I set it for, and usually is about 10-15 degrees below, with trying all of the different possible adjustment settings.
There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
I have been cooking Southern BBQ for 40 years, my Dad did the same. I have bought ever kind of grill on the market, built many of my own because none of the store bought grills cook very well and don't last because of cheap construction. Had been researching Pellet grills for some time and decided on the YS640. Received the grill yesterday and very impressed on everything from boxing to construction of the grill. Just fired it up to burn it in. Temp stays @350. This grill is well made, USA made ! Which is important to me. Cant wait to cook on it, know it will do the job. Thanks..All Things BBQ.....
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
Just like many other appliances available, the Davy Crockett pellet grill comes with Wi-Fi. It may seem absurd to pay more only because of the Wi-Fi feature, but every experienced outdoor griller will tell you that it can come in handy. If you want perfectly grilled or smoked food, you will need to keep your eyes on the temperature of the grill all the time. Taking your eyes off the thermometer for even a few seconds can result in your food being burnt. Because of this, the person behind the grill doesn’t get a chance to hang out with the rest.
Main products of our company :electric, home,toy,clother ,etc. Since its foundation ,the company keeps living up to the belief of ...:"honest selling ,best quality ,people-orientation and benefits to customers. "We are doing everything to offer our customers with best services and best products .We promise that we'll be responsible all the way to the end once our services begin This 4-quart Classic-style 10" Dutch features a beautiful white tail deer etching on the lid, three legs, a handled lid and bale. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood. Seasoned and ready to cook.Total Weight = 13 lbs.Depth: 3 1/4"Capacity: 4 QT.ID = 10"OD = 10.25"Model No: SDO10UPC Code: 033246208060 If you have any further questions, please feel free to contact us. We look forward to serving you in the future. read more
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.
Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
With that said, we also wanted to take into consideration the smaller grills of the family. For instance, we wanted to share pellet grills that were intended for portable use or individuals that want a small smoker that is of the best quality. As far as cost and value are concerned, we can say that all of the grills on this list are top of the line and have expert quality features that make them ideal for the individual that wants their ideal pellet grill.

Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
Second, more people know about them. More manufacturers are realising the advantages of pellet smokers and hopping on board, the market is expanding, and with the advantage of the internet putting all the info at our fingertips, even someone who hasn’t got the first clue about smokers and grills can find out everything they need in just a few minutes.
I have the larger Traeger smoker and have really liked it but not from the start. I had issues with the heating unit but the Traeger help people managed to get my “mechanical blondness” through this and all is well. The assistance center people at Traeger weres super supportive so I’m a loyal fan today. One thing I suggested to Traeger, and all who have a Traeger smoker, is to make the grill surface in two parts so it fits into a dishwasher. I cut my grill in half allowing it to fit in my dishwasher. Easy peasy to clean now!
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazon https://tinyurl.com/amazingribs
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
Most grills feature a primary cooking area (the main grate) and a secondary cooking area (additional racks). In a pellet grill, there’s less difference between the two grilling areas because it mainly cooks by indirect heat, so the temperature is the same throughout the grill. It’s best to pay attention to a pellet grill’s total cooking area because it is the sum of the primary and secondary cooking areas.
×