Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
With Davy Crockett’s Wi-Fi feature you will have more time to interact with your friends and family. Download the GMG’s app to your phone and you will be able to turn the cooker on and off, monitor and control internal meat temperature, and even receive system malfunction or low fuel warning. In addition, you can even add time and temperature instructions for your favorite recipes. For example, the grill can cook at 225°F until the internal meat temperature is 110°F. Then, the heat can be turned up to 500°F for browning until the temperature of the meat is 135°F. Lastly, the temperature can be dropped to 140°F to keep the meat warm.
Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Another pellet smoker from industry leaders Traeger. The Lil Tex Elite is an upscaled Junior Elite, and whilst it’s still a good quality smoker and grill with a powerful burner and excellent heat output, plus all of Traeger’s usual electronic gizmos. There’s just not enough of a difference between this and the Junior Elite, especially not when you consider the increased price tag, which is disappointing.
Next in our pellet grill review is the Green Mountain Davy Crockett pellet grill. Its small size makes it a portable grill. It weighs 57 pounds and measures 14.5 by 20 by 29.5 inches in dimensions. The Green Mountain pellet grill has 110V or 12V adaptors for 3 power options. It has foldable legs that also function as handles. This pellet grill also features a thermal sensor which monitors the grill temperature called Sense-Mate. One coveted feature on this pellet grill is that is Wi-Fi compatible.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.

One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.

The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).

How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.


One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.


This smoker offers a massive 560 cubic inches of grilling area with a large-capacity pellet hopper. Even though it’s the perfect starter grill, it’s still packed with plenty of extras that even the pro chefs will enjoy. If the grilling space isn’t enough, the removable upper racks can be turned into extra cooking space. The smokestack behind the unit can also be converted into a prep area.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.

The big structure makes it great for searing large amounts of meat at the same time. When it comes to high temperatures, you need to know that it only reaches 450~ degrees F. It’s not a lot, but you have to know that the main characteristic of this grill is maintaining low temperatures for a long time which allows for reliable, easy and slow meat searing.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Super excited to receive my brand new Traeger Timberline 1300 pellet smoker. When unboxing and putting together I noticed I was unable to attach legs due to damage to the unit. Instead of a nice round hole where legs would go, there was no holes, just where the hole should be smashed together. I instant contact Traeger and sent pictures of the damage requesting a new grill. They would not provide any case number and said they needed to review pictures which would take a few hours. 3 days goes but and no response. I open a PayPal dispute (NOT claim) and they contacted Traeger again. Now they refuse to do Anything unless I close the dispute but if I close dispute, I lose all my consumer protection. They could of handled this situation so much better. I will never purchase a smoker from them again. Horrible customer care.
The ceramic stone promotes even heat distribution and the domed ceiling design mimics the same heating pattern as a wood fired bri...ck oven. Preheats in just 15 minutes, exceeding 600°F if needed. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.
The Traeger Pellet grill can accommodate temperatures from 180 degrees to 375 degrees, and high. It has a state of the art digital temperature control system that not only monitors the temperature to keep it consistent and even, but also regulates the pellets the auger feeds to the fire according to that temperature. This is truly a grill worthy of a place in our pellet grill review.

My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
You are worried about flare-ups: When grilling fatty types of meat on a propane grill, you run the risk of having flare-ups, where the flame gets too high and too hot, burning the meat. You have to keep a close eye on the propane grill to guard against them. But with the Traeger grilling system, the even distribution of the heat and the indirect heating system prevent this problem.
There is a bit of a learning curve when cooking with pellet grills. This unit can smoke, grill or bake similar to an oven. The Traeger smokes at 180*, but can cook up to 450*. It is indirect heat, so you can grill a ribeye without flare ups. My unit holds temps within 5+/- of the setting. Yes, you do have to clean it like a fireplace, it doesn't run on gas. The build quality is amazing, especially for a PRC manufacture. If you are interested in a pellet grill, buy a pellet cookbook. Something that gives smoke and cook times for an easier introduction into pellet cooking. The only knock against the unit is that for $800 it should have came with the "optional" folding shelf...
FARMINGTON, Utah, Sept. 1, 2016 /PRNewswire/ -- Today, Vista Outdoor Inc. (NYSE: VSTO) announced it has acquired privately owned Camp Chef (Logan Outdoor Products, LLC and Peak Trades, LLC), a leading provider of outdoor cooking solutions. Camp Chef's high-quality products deliver efficient ways to cook for almost any outdoor gathering, from camping to dinner on the back patio. The brand offers more than 250 products including camp stoves, barbecue grills, pellet grills, smokers, fire pits, and a full line of cast-iron cookware and accessories.
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!

With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.

This piece of junk did not work when I received it fresh out of the box & now it's broke again!!! What a waste of money! First issue was a temp control module board, which the manufacturer actually sent me directly & I had to install it. Now after about 6 months of using it approximately 12-14 times, it won't even power up. I don't even want to attempt to fix it again!! I am going to spend the extra money & buy a Traeger!!
Camp Chef does offer one key accessory that most other pellet grills don’t have. We’re talking about the SmokePro BBQ Propane Sear Box. Most pellet smokers aren’t that good at searing. However, the Camp Chef made sure to address this issue. The sear box can reach up to 900°F and reverse sear four steaks perfectly. If you’re willing to overlook some inefficiency with the smoker, and searing your meat at high temperatures is important to you, then the Camp Chef SmokePro DLX could be the right smoker for you.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
Super excited to receive my brand new Traeger Timberline 1300 pellet smoker. When unboxing and putting together I noticed I was unable to attach legs due to damage to the unit. Instead of a nice round hole where legs would go, there was no holes, just where the hole should be smashed together. I instant contact Traeger and sent pictures of the damage requesting a new grill. They would not provide any case number and said they needed to review pictures which would take a few hours. 3 days goes but and no response. I open a PayPal dispute (NOT claim) and they contacted Traeger again. Now they refuse to do Anything unless I close the dispute but if I close dispute, I lose all my consumer protection. They could of handled this situation so much better. I will never purchase a smoker from them again. Horrible customer care.
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.
GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.

The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
Although our testers thought this grill was a bit heavy, they loved its small footprint and still found it to be very portable: “It’s a great size and convenient to bring in an RV or SUV for tailgating and grilling on the go,” reported one reviewer. Our testers were also pleased with how easily you could control the grill’s heat from its corresponding smartphone app. The only real downside? The instructions were a little unclear, according to one of our reviewers.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
It offers 700 sq. in. of cooking space and a powerful thermostat for a higher price, but makes up for it as soon as you start cooking on it. Also, it has a stunning design with the bull horns, which sets it apart yet again. But if you find yourself not spending as much and could do with a lesser cooking space, then the Camp Chef PG24 is a no-brainer for you.
Now, the best pellet grills come with more advanced features like auto-ignition using igniting rods, Wi-Fi Support, automatic turn on/off, and much more. One of the key safety features added by pellet smokers (designed by Green Mountain Grills), is a cooling fan to cool off the grill after it has been turned off. Even the shape of the body has been changed to have peaked lids so that it can accommodate turkeys and other kinds of roasts. Some come with multiple levels of racks for warming and cooling.

What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
But, along with some shelves we don’t need, a headboard that won’t fit our new bed, and a gigantic chest freezer I haven’t yet filled, the Egg has languished in the back corner of the garage since then. That’s because a brand new Traeger Timberline 850 was sitting here waiting for us when we arrived and it’s performed so well and become such an essential part of my cooking that now I can’t imagine using anything else. 
×