Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.
Hi i would like to buy my boyfriend a good quality smoker but can’t seem to find one that’s small for people just starting out with smoking for our small backyard. Does anyone have any suggestions? I don’t want to invest too much to start incase it’s too difficult to use or we find we don’t like it. I’ve read some reviews on little smokers that catch on fire and that worries me since we live in a townhouse. I figured someone on here would know of a well made brand that is on the smaller/less expensive side.

Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.

In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.

You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.


With that said, we also wanted to take into consideration the smaller grills of the family. For instance, we wanted to share pellet grills that were intended for portable use or individuals that want a small smoker that is of the best quality. As far as cost and value are concerned, we can say that all of the grills on this list are top of the line and have expert quality features that make them ideal for the individual that wants their ideal pellet grill.

Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?


Three and a half months ago, my fiancée and I loaded all our worldly belongings into a trailer and drove that stuff to our new house in Montana. As one of my most-loved things, the Egg was in there, carefully packed inside and out to make sure no part of it would break. Worrying about it riding back there was one of the reasons my average speed on that drive was just 47 miles per hour. 
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
Another avenue that many pellet grill owners use is participating in a bulk buy of their favorite brand.  Many times by ordering as little as a thousand pounds of pellets and having them shipped via pallet can save enough per pound to be worth the effort.  Also, check the websites of the pellet brands listed above, many have local distributors that maybe with an hour drive of your location.  If you are new to the pellet world, the thought of ordering a thousand pounds of pellets may sound excessive or intimidating.  Many felt this way at first, but if you are in a location where it is hard to get pellets, the mantra of keeping at least a hundred pounds of pellets (five 20 pound bags) on hand at all times starts to make sense quickly.
You then simply select your desired temperature via the digital controls and relax, safe in the knowledge that the temperature will stay steady and there won't be any dreaded hot or cold spots. This consistence is achieved through the efficient temperature control system and automated auger. This ensures a deep smokey flavor is embedded in your meat every time.
The Memphis Elite is the largest cooker in Memphis Wood Fire Grills' impressive line of luxury pellet smokers. They're extremely well designed and well built. The top-grade 304 stainless steel is thick and extraordinarily well machined. Fit and finish are impeccable. Meathead proclaims Memphis smokers to be "some of the best cookers [he's] ever had the pleasure to use." At $4,999, the Elite is clearly not in everyone's budget, but this beast is impressive enough for us to include in our 2016 Top 10 Luxury Grills and Smokers list, where prices go up to $50,000.
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.

It is great when it comes to smoking meat at low temperatures, regular grilling, baking or roasting. You can have problems, though, if you want to sear your meat, it requires much higher temperatures. Sadly, a regular pellet smoker cannot reach them. In that case look around for a pellet grill that comes with an additional sear box that is gas fueled and can heat up to 900 degrees F.


Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.
After an hour on tech support, taking the thing apart, they acknowledged the auger motor was bad and they would send me one. This would be FANTASTIC if I had owned the grill for a year or so and the company was standing by their product... but to insist on sending me a part to a BRAND NEW GRILL and having me replace it...Unacceptable. When I asked for a new replacement hopper system (I get it ... things break... and I'm willing to meet them halfway) they said no... just the motor. I would have kept it had they allowed me to swap out the entire hopper system but I shouldn't have to do surgery on a brand new piece of equipment. Please don't buy this poorly made (China) piece of trash.
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.

Our reviewers spent 12 hours testing a top-selling, budget-friendly pellet grill. To get the most comprehensive feedback possible, we had our testers take this grill for a spin and had them consider its most important features — from how much it can cook at a time to how easy it is to travel with. We've outlined the key pointers here so that you, too, know what to look for when shopping.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.
The simplicity with which you can use this product is outstanding. From the time that you put it together to the time you smoke meat to the time you clean it, the entire process is extremely simple. It has a power failure restart and a dump tray that can easily be cleaned out. The cooking surface is so large that it is possible to smoke two turkeys at once.

Apart from the replacement parts for a pellet smoker, there are also certain accessories that one can use to increase the range of its usefulness as well as improve its performance. A user can attach a griddle attachment to a pellet grill to use it as a flat top griddle, or use a hopper extender to increase the pellet hopper capacity; there is an attachment for every purpose to suit all of your needs. Let’s take a look at the types of accessories commonly found:
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.

My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
My fiancée's family has never really understood me. They see my safe full of guns, the knives I gift her on birthdays, and my preference for the company of dogs over humans, and despite her assurances to the contrary, they see a hick. So, one night while her sister and her husband were visiting from L.A., I cooked them venison backstrap for dinner. They were extremely hesitant, but as good sports, gave it a try and were absolutely delighted. And you know how I made it? I Googled venison backstrap, plus Traeger, and followed the instructions. 
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).
×