Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.

The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®. By submitting this rebate form, you agree to resolve any disputes related to rebate redemption by binding arbitration and you waive any right to file or participate in a class action. Terms and conditions available at www.rebateinternational.com®
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.
Louisiana Grills is a respected brand when it comes to pellet smokers. It was one of Traeger’s earliest competitors that entered the market after the original Traeger patent expired. The biggest difference between the two brands is that Louisiana Grills makes pellet smokers with advanced features for a relatively affordable price. The Louisiana Grills LG700 is no exception. It has a one-touch PID controller, a programmable meat probe, an adjustable flame broiler for direct grilling, an upper cooking rack and a lower storage shelf.
I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!

Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.
Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.

Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?


Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.

My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!


The moment we found this as one of our most desired articles, we had to conduct extensive research on what a pellet grill is. With that said, if you are new to the pellet grill industry and want to know what it is, here we go! Pellet grills are often considered, ‘pellet smokers’, due to the construction quality and design. The reason is that pellet grills combine different cooking elements such as charcoal, gas grills, and a conventional kitchen oven. Now, they are fueled by wood pellets, hence the name. With that said, pellet grills can smoke, cook, and grill all in one simple mechanism and design. With an electronic control panel, an individual can control the wood pellets that fuel the fire to regulate airflow and maintain the proper cooking temperature. Did you get that? We hope so because it is time we share with you the criteria to evaluate the best pellet grills.

We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.

With 440 square inches of cooking space, an auger-fed pellet delivery system, and a digital LED thermostat and controller, your cooking will be simple, whether it’s burgers, a whole turkey, or racks of ribs. The side shelf is a convenient place for cooking tools or plates while the bottom shelf can hold spare bags of pellets or jugs of sauces out of the way.
If you’ve used a pellet grill in the past, you’ll be familiar with its combination of wood smoke flavor and easy, digital temperature control. What the Timberline 850 adds are higher temperatures—up to 500 degrees—the ability to lower the main grill rack closer to the fire for better searing, double-walled construction that better insulates the grill from outside temperatures, and wireless connectivity that allows you to monitor grill and probe temperatures from your smartphone. Those might sound like small changes, but together they make for a sleeker grill with an appreciable increase in capability and convenience. Being able to watch the internal temperature of a piece of meat remotely is particularly useful and has helped ensure that not a single thing I’ve cooked on the Timberline has been overdone. 
With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.
I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body. 

Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
You want a set-it-and-forget-it option: Traeger grills work best when they’re allowed to cook and smoke the food over long periods of time. As long as the system has fresh wood pellets in the hopper to feed the fire box, it will be able to maintain a steady temperature. So you can set up the grill and then leave it for half an hour, a couple of hours, or even longer, something that’s difficult to do with other grilling systems.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
This piece of junk did not work when I received it fresh out of the box & now it's broke again!!! What a waste of money! First issue was a temp control module board, which the manufacturer actually sent me directly & I had to install it. Now after about 6 months of using it approximately 12-14 times, it won't even power up. I don't even want to attempt to fix it again!! I am going to spend the extra money & buy a Traeger!!
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
The 4 Life Outdoor Kitchen: built-in BBQ Grill The 4 Life Outdoor Kitchen: built-in BBQ Grill Cabinet is skillfully made from 304 stainless steel and is delivered to your home fully assembled. The weather resistant doors are protected with a white UV-resistant powder coating offering long-term resistance to corrosion and rust. These cabinets are built strong with precision ...  More + Product Details Close
I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.
I have been cooking Southern BBQ for 40 years, my Dad did the same. I have bought ever kind of grill on the market, built many of my own because none of the store bought grills cook very well and don't last because of cheap construction. Had been researching Pellet grills for some time and decided on the YS640. Received the grill yesterday and very impressed on everything from boxing to construction of the grill. Just fired it up to burn it in. Temp stays @350. This grill is well made, USA made ! Which is important to me. Cant wait to cook on it, know it will do the job. Thanks..All Things BBQ.....

It is different with REC TEC Wood Pellet Grill, here the solid construction is made of high quality materials. On the outside, high temperature powder coat and porcelain enamel finish. While inside, the manufacturers use stainless steel of very good quality for all the major parts. On the official website, we can read that you can find over 40 pounds of 304 stainless steel parts in this grill ( see for yourself ).
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
Make dinner for the family with the Camp Chef 12-Quart Grand Canyon Cast Iron Dutch Oven. This unequaled cookware is designed with... a beautiful scene of the Grand Canyon featured on the outside to commemorate 100 years of the national park. The Camp Chef cookware is not only attractive; it is useful as well. The deep-dish lid doubles as a skillet or serving trivet, and the pot comes preseasoned so it is ready to use. The Camp Chef Dutch oven includes a lift tool so you can carry the pot from the stove to the table with ease, and a thermometer channel allows you to check the temperature without lifting the lid, so the heat stays inside. This cookware is just what you need for camping trips to cook for the whole family. It is large enough to feed everyone, and it is sturdy for cooking over alternative heat sources. The unique lid that doubles as a skillet helps save room when you pack up for a weekend camping. read more
Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.

Traeger invented the original wood-fired grill over 30 Traeger invented the original wood-fired grill over 30 years ago in Mt. Angel Oregon and continues to lead the industry as the worlds #1 selling wood-fired grill perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller means ...  More + Product Details Close
The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Wood pellet grills are a great addition to any home because they combine everything you love about a smoker with a standard grill. Depending on the model that you buy, you can make smoked dishes like brisket and sausage at the same time that you make burgers, hot dogs and other dishes on the grill. These grills are great for family dinners in the summer and for parties and special occasion celebrations.
After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.

The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.

I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.

I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
Temperature: Most of all, you have to pay attention to whether your pellet grill maintains a chosen temperature. People buy a pellet smoker because it makes it possible to smoke meat for long at fixed low temperatures. Very convenient and simple, and a grill that always maintains a selected temperature guarantees that the meat will be perfectly cooked.
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
A: Now, this next key question is one of the most asked questions and we can see why. For the new individual that wants to know how long pellets will last. There really is no overall actual answer because it all depends on the size of the grill and the heat that the grill is on. With that said, a nine-pound bag of pellets can last as long as 2.5 hours at a heat of about 225. However, the higher the heat the quicker it will cook.

Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.


Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.


This handsome KitchenAid 36 in. Built-In Island Gas This handsome KitchenAid 36 in. Built-In Island Gas Grill Head is constructed with premium corrosion-resistant materials for durability and ease of upkeep. Boasting 931 sq. in. of total cooking space this unit thrusts up to 71 000 BTUs of fire-roasting energy across four main stainless steel burners one ceramic infrared ...  More + Product Details Close
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
×