Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
Consumer-level Traeger grills are considered a mid-range type of pellet grill, so they’re good for those wanting to try pellet grills for the first time. Traeger models like the Lil’ Tex Elite 22 or the Tailgater cost several hundred dollars and can grill about 12 to 16 burgers at a time. Larger Traeger grills will generally carry low four-figure prices, such as the Pro Series 34 or the Select Pro, which can hold 32 to 40 burgers between the upper and lower grilling racks.
Make dinner for the family with the Camp Chef 12-Quart Grand Canyon Cast Iron Dutch Oven. This unequaled cookware is designed with... a beautiful scene of the Grand Canyon featured on the outside to commemorate 100 years of the national park. The Camp Chef cookware is not only attractive; it is useful as well. The deep-dish lid doubles as a skillet or serving trivet, and the pot comes preseasoned so it is ready to use. The Camp Chef Dutch oven includes a lift tool so you can carry the pot from the stove to the table with ease, and a thermometer channel allows you to check the temperature without lifting the lid, so the heat stays inside. This cookware is just what you need for camping trips to cook for the whole family. It is large enough to feed everyone, and it is sturdy for cooking over alternative heat sources. The unique lid that doubles as a skillet helps save room when you pack up for a weekend camping. read more
This smoker offers a decent 418 square inches of grilling space. This is enough to cook around sixteen burgers or four whole chickens. If the grilling space isn’t enough, Traeger also offers a larger unit that offers the same features at a higher price range. But the medium sized one is enough to cook for large groups of people already. Built to have a high capacity, this smoker allows for multiple cooking at the same time.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
The smoker is great. (5 stars) Assembly went well. It's pretty straight forward. Operation is easy as well. Just set and pretty much forget it. This is a large smoker. If you need space, this is the one for you. This is my first pellet smoker so I can't offer any comparison to others. I've used a Brinkman horizontal smoker for the last 20 years that has worked well but it was a pain to keep the smoke and temperature where you want. The constant tinkering was getting tiresome. The ease of use of the Camp Chef makes things so much more enjoyable.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
Vista Outdoor is a leading global designer, manufacturer and marketer of consumer products in the growing outdoor sports and recreation markets. The company operates in two segments, Shooting Sports and Outdoor Products, and has a portfolio of well-recognized brands that provides consumers with a wide range of performance-driven, high-quality and innovative products for individual outdoor recreational pursuits. Vista Outdoor products are sold at leading retailers and distributors across North America and worldwide. Vista Outdoor is headquartered in Utah and has manufacturing operations and facilities in 13 U.S. States, Canada, Mexico and Puerto Rico along with international customer service, sales and sourcing operations in Asia, Australia, Canada, Europe and New Zealand. For news and information, visit www.vistaoutdoor.com or follow us on Twitter @VistaOutdoorInc and Facebook at www.facebook.com/vistaoutdoor.
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.
Due to having such features and being the best Lousiana Grills Product, the Louisiana Grills LG Pellet Grill 1100 could not escape our vigilant gaze when we did our research. However, it had some shortcomings, mainly due to its build and price that did not allow it to make it into our pellet smoker review. Regardless, we could compare it with some of our products that it had tied with. But as always, we could only choose the top 10 products for this review and this had to go. Regardless, this still is a great product, worth mentioning.

Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
Yo, Kevin! Hope that you can soon review one of my all-time favorite purchases, the Traeger Li’l Tex Elite Smoker/Grill. After using it for a couple of months, I gave away my two year old gas-grill to my grandson. We’ve done chicken, turkey, pheasant, lamb, all kinds of beef, pork and sausages including some wonderful ribs and brisket. Our Easter Rib Roast turned out terrific as did the chunks of assorted sausages that we did for another family get-together. I was never a big fan of grilling until we got our Traeger. Both Traeger and the web-sites like yours are full of great recipes and ideas.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!

Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
Rest the cast iron press on your skillet or griddle to warm. Use the press on top of bacon to speed cooking times as it cooks from... both sides. Use as a hot press with your favorite sandwiches to turn them into a hot and melty favorite. The grill lines from the ridged bottom will sear the sandwich for a tasty presentation. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork

Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
This heavy-duty top-notch grill and smoker has a total cooking area of 429 square inches, which is large enough for cooking around twenty burgers at once. If that’s not enough, it comes with a secondary rack of 144 square inches that you can use for smoking or warming. With a height of 32.5 inches, you can cook a variety of meats and foods to your heart’s desire.
It may have taken a few years to catch on, but it’s hard to dispute that pellet grills are here to stay.  Pellet grills are easily the fastest growing segment in the grilling industry.  This has left many new pellet grill owners with a few questions concerning pellets.  Chief among them “what constitutes a good pellet?”   Second, “where can they find pellets to fuel their prized grill?”

With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
The temperature control unit is easy to use and relatively good. To start it, all you have to do is push one button.When it comes to the unit itself, the REC TEC RT 680 is, in general, thick and well built. Unfortunately, the reported temperature can differ from the actual temperature due to airflow inconsistencies inside the cooking chamber. The maximum temperature this grill can reach is 500°F.

Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.

In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.


Due to having such features and being the best Lousiana Grills Product, the Louisiana Grills LG Pellet Grill 1100 could not escape our vigilant gaze when we did our research. However, it had some shortcomings, mainly due to its build and price that did not allow it to make it into our pellet smoker review. Regardless, we could compare it with some of our products that it had tied with. But as always, we could only choose the top 10 products for this review and this had to go. Regardless, this still is a great product, worth mentioning.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic. 

This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
Yoder YS 640 is built out of durable materials. Unfortunately, this means that it is heavier than some other units. It weighs 325 lbs, nearly twice as much as the Traeger Texas Elite 34. The main body is built out of 10 gauge metal. It will take more time to reach the highest temperature, however the smoker will hold the heat in far better than some other cookers.
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.
Speaking of competition cooks, you’ll find that many competition BBQ pitmasters who use Pellet grills as their primary means of cooking are among the more well rested come Saturday. The next step we’ll cover in this selection of Pellet Grill Reviews is getting your pellet grill / smoker up and running. Again, what you may not see in may Pellet Grill Reviews is repeated mention that you’re not going to get that “deep smoke” flavor profile using a pellet smoker. Though, this can be achieved by using something like the Amazen Pellet Tube Smoker 12″.
Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
As you could probably guess from the name of these smokers, they run by burning wooden pellets. Typically, a pellet smoker comes with a hopper on the side where the pellets are added. When you turn on the smoker, pellets will move from a hopper to a burn pot where they will be burned and the smoke will be diffused by a fan. A thermostat measures the temperature of the grill and determines how many pellets to burn while keeping a consistent temperature.
×