I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.

This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
A few other mentionable features are that it has a highly durable temperature proof textures powder coat finish, it features auto start. The REC TEC Wood Pellet Grill accommodates temperatures from 180 degrees Fahrenheit to 500 degrees Fahrenheit with 5 degrees increment. This amazing temperature control features let you be in control of how much heat you want to cook your food in, without having to worry about it getting dry or burnt. This low increment allows you to cook delicate meats like fishes and seafood as well! It smart grill tech makes sure that the temperature you set is always consistent and constant. It also has an “Extreme” smoke feature from the 180 to 250 degrees Fahrenheit setting that intensifies the smoke in the grill.

I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.


The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.

For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.
I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.

160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
Provide year-round protection for your grill with this Provide year-round protection for your grill with this Dyna-Glo Premium BBQ Cover. Made with water resistant heavy duty PVC shell and 900 Denier polyester lining to withstand harsh elements. Double-stitched seams provide additional strength and durability to help prolong the life of the cover. This cover also features durable nylon ...  More + Product Details Close

Kevin, your recommendation rocked. The Pro is one of the best pieces of grilling and smoking iron I have had my hands on in a long time! Better than the Backwoods? Well depends on how much work you want to do! Maybe not, they are first class, but ease of use? I use the Backwoods a couple times a year, the Pro has already done 8 cooks in 5 weeks. Love it.
4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
Bought a YS-640 in 2012 and have been an avid supporter of Yoder pellet grills. Cooks great and very solid construction. Technical support started out phenomenal but seems to be less competent now. Have replaced the thermocouple every two years, almost to the month (pellet grill gets used 1-2 times per month, at low temp 275 deg F cooks). Really disappointing thermocouple life for a $1500 pellet grill. Still love the way it cooks but I have to keep a spare thermocouple in my tool box so I don't have an issue on my cooks.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
It is great when it comes to smoking meat at low temperatures, regular grilling, baking or roasting. You can have problems, though, if you want to sear your meat, it requires much higher temperatures. Sadly, a regular pellet smoker cannot reach them. In that case look around for a pellet grill that comes with an additional sear box that is gas fueled and can heat up to 900 degrees F.
In my experience, running Traeger pellets, the grill has functionally three temperature settings;  1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table.  2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs.  3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho.

Super excited to receive my brand new Traeger Timberline 1300 pellet smoker. When unboxing and putting together I noticed I was unable to attach legs due to damage to the unit. Instead of a nice round hole where legs would go, there was no holes, just where the hole should be smashed together. I instant contact Traeger and sent pictures of the damage requesting a new grill. They would not provide any case number and said they needed to review pictures which would take a few hours. 3 days goes but and no response. I open a PayPal dispute (NOT claim) and they contacted Traeger again. Now they refuse to do Anything unless I close the dispute but if I close dispute, I lose all my consumer protection. They could of handled this situation so much better. I will never purchase a smoker from them again. Horrible customer care.
Watch movies outdoors with the Camp Chef Outdoor Movie Screen 144". This product features a 44" (12 ft) diagonal screen with a wid...e screen, 16:9 aspect ratio for optimal image sizing and viewing. The 600D x 600D oxford nylon material offers a striking, quality picture. Protected with a 1" diameter frame and 18-gauge powder-coated steel tubing, this Camp Chef screen is durable for long-lasting use. It also comes with a carrying bag for easy transportation and storage. read more
Rubbery skin has very little to do with the type of heat (direct vs indirect). Rubbery skin is a result of too low a cooking temperature. Take your smoker/grill or whatever you use and get the temperature in the mid 400’s or even higher and you will get crispy skin. One thing though never let the internal temperature of your bird get over 150 or you’ll have crispy skin and dry crunchy meat too. Take it off the grill and let is rest a full 30 minutes. Best bird you’ll ever eat no matter which grill, smoker, 50 gal barrel, etc you cooked it on.
Are you sick and tired of bad BBQ? Well, so are your friends, neighbors, and family members. With the Woodwind woodfire pellet grill, mediocre grilling can be a thing of the past. Put the bland chicken and burnt steak behind you, and become the grill master you were born to be. With digital temperature control, the Woodwind does all the work for you. All you have to do is turn it on, set the temperature, and let it work while you play. Which means no more babysitting! The Woodwind doesn’t just make grilling easier—it also makes it more delicious. The Woodwind is fueled by premium hardwood pellets to generate heat and smoke, infusing your food with a savory wood fire taste that’ll make your taste buds sing. With grill temperature settings from 160° F to 500° F and the included Sear Box that reaches up to 900° F, you can achieve perfect results, whether you’re grilling, smoking, baking, roasting, braising, barbecuing, or even searing. And when you’re finished cooking, cleanup is a breeze with our patented Ash Cleanout system. Discover the heavenly taste of a woodfire pellet grill with the Woodwind. Buy now to begin your journey to grill mastery.

Although our testers thought this grill was a bit heavy, they loved its small footprint and still found it to be very portable: “It’s a great size and convenient to bring in an RV or SUV for tailgating and grilling on the go,” reported one reviewer. Our testers were also pleased with how easily you could control the grill’s heat from its corresponding smartphone app. The only real downside? The instructions were a little unclear, according to one of our reviewers.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.

It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.


Traeger Junior Elite Pellet Grill is a great model for those who want to start up the smoker, add some meat, and let the work be done for them. It is also extremely versatile, allowing you to grill, smoke, roast, and bake. It is perfect for individual households, college students, and even tailgating. And it’s a great option for first timers as well as those who have experience using pellet smokers.
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features commonly found in other GMG products that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
Even if you’ve got a meat thermometer at home, it’s not a bad idea to pick up a smoker with one built in. This is because the built in thermometers send their readings straight to the smokers computer and it automatically adjusts how it’s cooking based not just on how hot it is inside, but how this affects what you’re cooking. Now, unless you’re Gordon Ramsey you probably can’t tell what’s going on inside that turkey you’re cooking, so this is obviously a major plus.
What are your thoughts about the Kalamazoo hybrid grills? From what I’ve found online, you have the choice of gas, charcoal and wood for cooking or combinations of all. I have no first hand experience with Kalamazoo but it seems very versatile? At the moment after a month of researching, I’m leaning towards a Mac/Yoder or a Webber spirit & egg or a Memphis….so in other words, I’m no closer to a decision than when I started. I currently have a 9 yr old treager that won’t break, seriously, I’ve only repainted once with rustolium….dang thing won’t break so I can get a new toy. I sear in a skillet in the kitchen. My treager has the smoke/med/high switch and I want more control, I’ve maxed what I can do and it’s a challenge in cold weather and wind but it was a great start when they were made to last, more than got my money’s worth. I cook at all levels from smoking to grilling. I do love pellets and don’t want an egg but enjoy the food as much as the process of preparing it. Ok probably to much info but money aside, will you list your recommendations of what you think is best for me?
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
Pellet Hopper – One of the reasons we all buy a pellet smoker for is the long cooking time. It’s an automated grill, but it needs to be provided with the right amount of pellets in the hopper. Those grills are used for long, often all night long meat smoking. That’s why it’s important for the pellet container to be very big. Here you get a 40 pound hopper capacity. You can be sure you won’t run out of fuel during longer cooking.
×