Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.


Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.
I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.

3-DFT12 Size: 12" Features: -You can now take the guesswork out of outdoor grilling and concentrate more on the beauty of the grea...t outdoors. -Allow yourself to effortlessly monitor and regulate the temperature of your grill with the Camp Chef Thermometer. Product Type: -Thermometer. Finish: -Silver. Tool Head Material: -Other. Number of Items Included: -1. Dimensions: Overall Product Weight: -1 Pounds. Size 6" - Overall Height - Top to Bottom: -6 Inches. Size 6" - Overall Width - Side to Side: -2 Inches. Size 6" - Overall Depth - Front to Back: -2 Inches. Size 12" - Overall Height - Top to Bottom: -12 Inches. Size 12" - Overall Width - Side to Side: -2 Inches. Size 12" - Overall Depth - Front to Back: -2 Inches.Package Quantity : 1 read more
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Bake, braise, grill, smoke, and sear – all of these cooking techniques can be fully experienced by just using one unit of backyard cooker! Yes, you can definitely do different kinds of cooking to your pork, beef, fish, pizza, or pie by just using the Camp Chef Smokepro STX Pellet Grill without burning charcoals and woods to start the cooking process.

First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
The Smoke Pro SE Pellet Grill brings award-winning barbecue to your back patio. Simply select the desired cooking temperature and ...let the smoker do the rest. Our Smart Smoke Technology maintains a consistent temperature range to produce as much smoke as possible. That means the best flavor possible. And at the end of the cookout, you’ll enjoy the easiest, quickest cleanout system in the industry. Instead of dismantling and cleaning your grill after every use, you can pull a lever and empty the ash out of the fire pot. In a few seconds, you’re ready for your next big barbecue. And it’s good thing too, because that smoky taste is going to keep everyone coming back for more. read more
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission. 

My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.

With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
3.) Had everything set up to bake pizza's . Started up the grill. Installed pizza oven in grill. After about 1 hour grill only got to 280 degrees. Desided we needed to eat dinner and 2 pizza already mad up I placed the pizza's in the grill. 3 minutes later yhe temperature started to go down. Finaly after grill was at 80 degrees I received a message that there was no fire. I removed the pizza oven with pizza's still in. The fire box was full of pellets not burned. I reset the grill and started it back up and no fire message again. Grill is broke again . Only had this grill for 5 months, usef it 6 times and 3 of the times it ruined my cookout.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
Customer Service: I spoke with customer service department about 10 times during this process, and every time I emailed or called I received a different person in response to my same issue. This did not feel good as I never got past the ground level in service even asking for upper management. After the initial response to the dented barrel I received a month back order request for a replacement. After this no offer was made to remedy the situation meaning no refund, or any extras were given as a sorry. I had to contact 3 more times (with three different people) asking for upper management before they agreed on making up for the situation. I ended up receiving for "free" a folding front tray. A month and week later I received my replacement barrel only with no lid, and then a week and half later received the lid.

As far as backyard cookers go, Pellet Grills are the newest products on the market. With their roots in the 1970’s, these versatile outdoor grills combine the capabilities of a traditional grill, with the wood-fired flavor of a smoker, and even the convenience of a modern oven. The “Pellet” in the name refers to the specific variety of fuel used. These are specially made cylinders constructed of compressed sawdust. The grill is powered by electricity and doles out specific amounts of pellets to maximize fuel efficiency. The primary benefit of these types of grills is their versatility. Wood pellets can be burned at all different temperatures and volumes, making it possible to sear, smoke, or slow cook a whole array of meats in an infinite variety of styles.


There is a bit of a learning curve when cooking with pellet grills. This unit can smoke, grill or bake similar to an oven. The Traeger smokes at 180*, but can cook up to 450*. It is indirect heat, so you can grill a ribeye without flare ups. My unit holds temps within 5+/- of the setting. Yes, you do have to clean it like a fireplace, it doesn't run on gas. The build quality is amazing, especially for a PRC manufacture. If you are interested in a pellet grill, buy a pellet cookbook. Something that gives smoke and cook times for an easier introduction into pellet cooking. The only knock against the unit is that for $800 it should have came with the "optional" folding shelf...
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this. 

What about temperature control and a digital controller? It is much poorer in this regard than the competitive Camp Chef which is why I decided to give the second place to Z Grills as an alternative to Camp Chef PG24. Therefore the digital controller allows to set the temperature within the range of 180-450 degrees F. A pretty low maximum temperature but it shouldn’t be a problem to enthusiasts of long slow cooking, which usually takes place at lower temperatures.
Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!
Bake, braise, grill, smoke, and sear – all of these cooking techniques can be fully experienced by just using one unit of backyard cooker! Yes, you can definitely do different kinds of cooking to your pork, beef, fish, pizza, or pie by just using the Camp Chef Smokepro STX Pellet Grill without burning charcoals and woods to start the cooking process.
×