You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features commonly found in other GMG products that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.

I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.

This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.


Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
With 440 square inches of cooking space, an auger-fed pellet delivery system, and a digital LED thermostat and controller, your cooking will be simple, whether it’s burgers, a whole turkey, or racks of ribs. The side shelf is a convenient place for cooking tools or plates while the bottom shelf can hold spare bags of pellets or jugs of sauces out of the way.
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.
The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 — using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
It’s also worth double checking the precision of the controls. Less expensive smokers sometimes have cheap control panels that only allow you to set the temperature to a few discrete settings, for example just low and high. This is, generally speaking, awful, and leads to improperly cooked meat and a whole host of other issues. Avoid it if you can.
There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.

The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.


The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.
Convection is achieved using a number of techniques. Air is fan forced into the grill and channeled throughout by our arched flame broiler. Our exhaust design allows air to circulate evenly along the length of the grill and to the top shelf. This combination allows us to achieve uniform heat throughout the unit whether your smoking at 170°F or cooking all the way up to 600° Fahrenheit.

Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one.  

The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®. By submitting this rebate form, you agree to resolve any disputes related to rebate redemption by binding arbitration and you waive any right to file or participate in a class action. Terms and conditions available at www.rebateinternational.com®
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
The first thing to consider before purchasing a pellet smoker is your budget. This will allow you to buy the best pellet smoker for the money. If you are a beginner, you do not need to get an expensive unit in order to produce results. However, if you have some experience and you want to take your smoking to the next level, you may look into a more expensive model with the goal of getting some of the features you want.
It may have taken a few years to catch on, but it’s hard to dispute that pellet grills are here to stay.  Pellet grills are easily the fastest growing segment in the grilling industry.  This has left many new pellet grill owners with a few questions concerning pellets.  Chief among them “what constitutes a good pellet?”   Second, “where can they find pellets to fuel their prized grill?”
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
Seeking to produce the pellet cooker that is both a great smoker and a powerful grill. The truth is that burning pellets in a controlled way is not the best method for producing high grilling temperatures. Most pellet grills top out at 500 degrees F while the hottest units can hit 600 degrees F. This pellet cooker is in reality, a combination grill with a large smoking space, and a small but powerful direct grilling area. Reasonably priced with quality construction, this is definitely a pellet grill to look at.
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
At Grills Forever, we work hard to bring you the best product reviews possible through an extensive online research process. We go through countless online reviews and browse through different brands, both known and unknown. We then go through their features and the value they can provide to the users. We shortlist the top products to do physical testing and then come up with a review. We do this on a regular basis to keep our list up-to-date.
So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
When you think of a pellet smoker, what comes to mind is the rich taste of BBQ, better manipulation and convenience. These are exactly what the best pellet smoker should give you. To find out the best, among the many out there, you should think of various features. A burner that can give you control, comfort, long service, and great flavor in food is something a top rated pellet smoker should have. Let’s take a look at all the factors you should consider when making your purchase.
Ordered Renegade Pro, received it and missing 6 washers to assemble the legs. They are rattling around inside the unit making it unusable. The control knob also sheared off in shipping. Traeger has yet to come up with a solution to fix or replace the unit...disappointed in their customer service. They don't care about customers after they get their money.
As I mentioned at the start of this post, there are a few pellet smokers that lead the pack in terms of name recognition. The ones featured here are those that come most highly recommended by friends of mine on the professional BBQ circuits with KCBS and FBA. As such, if you don’t see one of your favorites listed here and would like to offer up a review — please contact me via any of the social media links at the top of this blog’s sidebar, and we’ll see about getting a post up.

As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.

You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.

Cleaning other types of smokers typically includes scooping ash from the burners and removing burnt remains from the racks. Traeger turns this messy process into a very simple one. The smoker burns pellets so efficiently that there is almost no ash left behind. Since there is no direct flame, the cooking grates will not get sticky and caked with excessive amounts of burnt, juicy meat. In order to clean the racks, all you have to do is brush them quickly and then wipe them with a paper towel.
Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
As a conclusion, it’s a very good pellet smoker & grill. Main advantage is the sear box that runs on propane, allowing to reach temperatures of up to 900 degrees F. Definitely a very useful feature during cooking. Another interesting feature is Smart Smoke Technology, which allows to create much more smoke while maintaining the desired temperature.

Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.
I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
†Advertiser Disclosure: Many of the card offers that appear on this site are from companies from which CreditDonkey receives compensation. This compensation may impact how and where products appear on this site (including, for example, the order in which they appear). CreditDonkey does not include all companies or all offers that may be available in the marketplace.

The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.

This next video is great because it really talks about how solid the construction of the Rec Tec Grill Pellet Smoker is. You’ll note several times that the reviewer says how surprised he was at how heavy the lid of the cooker is. Folks, nothing… and I mean NOTHING cooks as well and as evenly as Heat Soaked Metal! That’s why cast iron is so prized for cooking ability! Also pay attention to the heat probe readings you see in this video. The one thing everyone who has used this pellet smoker says is that the Rec Tec Grill keeps actual temps where set temps read better than nearly any other pellet cooker out there.

The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually. 

Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.

Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it! 

This stylish BBQ Island is booth stunning and This stylish BBQ Island is booth stunning and well equipped; Standard features include a G4 4burner grill stainless steel refrigerator side burner and 30 in. double access doors. The porcelain design countertop with the Stack Stone base easily matches your Home Resort design and style. For added comfort add an ...  More + Product Details Close


This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
I’ve been grilling and smoking for many years and throughout all those years I have burned through many expensive grills. Four years before I purchased the 640 I got on the pellet smoker wagon and started my research. Finally when my daughter was getting married she ask me to cook for the wedding and gave me the perfect excuse to finally get a smoker I wanted. So getting back to the research and after 3 months of comparing I settled on the YS640. I wanted a grill, at my age, to be able to pass down to one of my kids. It was big investment but like I’ve learned in life, you get what you pay for “most” of the time. I have had this grill now, September 2018, will be 4years now. I have no regrets and would do it again. I’ve had some minor corrosion issues and after an email was promptly sent the matching paint to clean it up. I spent the time to do it right and today, a month later, today my grill looks brand new. Honestly nothing like this can be left to take care of itself. Maintenance like anything else is required. But I know this will most likely be my last grill. Thank for a great product and great follow up service. Smoke Shack.....

Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.


Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.

The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.
Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.
Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.

As you could probably guess from the name of these smokers, they run by burning wooden pellets. Typically, a pellet smoker comes with a hopper on the side where the pellets are added. When you turn on the smoker, pellets will move from a hopper to a burn pot where they will be burned and the smoke will be diffused by a fan. A thermostat measures the temperature of the grill and determines how many pellets to burn while keeping a consistent temperature.

×