Still loving it after cooking about 100 meals. Thru rain, snow, and the occasional nice day it is still going. Today I'm about to grill brats. My weber grill sits around rarely needed so it's going to get sold. I discovered with quality pellets it can grill just fine to temps up to 450. The camp chef grill cover keeps the pellets dry in the hopper so I don't even take them out unless you want to change flavors. I did have to seal the hopper handle around the rivets to keep the rain out but other than that it is very tight. See the pic makes smoke like crazy.
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Today I grilled up a T-Bone steak. And I used the Grill Grates. I upped the temps to 600 degrees. The T-Bone came out FABLULOUS!!! Actually, it cooked faster than I expected, and the sear marks were way better than I expected. I have been using Weber Gas Grill for many years and way satisfied with the results, but the Yoder smoker kicks ass...BRAVO YODER!!
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.

Cleaning other types of smokers typically includes scooping ash from the burners and removing burnt remains from the racks. Traeger turns this messy process into a very simple one. The smoker burns pellets so efficiently that there is almost no ash left behind. Since there is no direct flame, the cooking grates will not get sticky and caked with excessive amounts of burnt, juicy meat. In order to clean the racks, all you have to do is brush them quickly and then wipe them with a paper towel.
Lauded for its amazingly accurate cook temperatures and times and for affording cookers a real “unfair advantage” at competitions (according to those who lose to them) — Fast Eddy’s Cookshack Pellet Smokers rank among the very best available on the market today. I love the history of Fast Eddy’s pellet smokers. In 1986, Ed Maurin (Fast Eddy) — a retired KCMO Fire Fighter — cooked his first American Royal event. From that point on he was hooked on BBQ and on coming up with the very best way to ensure its production. By 1998 the first of his Fast Eddy’s pellet smokers was released to the market, and he was off to winning competitions and helping those who bought his cookers do so as well.
Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
The ceramic stone promotes even heat distribution and the domed ceiling design mimics the same heating pattern as a wood fired bri...ck oven. Preheats in just 15 minutes, exceeding 600°F if needed. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
You are worried about flare-ups: When grilling fatty types of meat on a propane grill, you run the risk of having flare-ups, where the flame gets too high and too hot, burning the meat. You have to keep a close eye on the propane grill to guard against them. But with the Traeger grilling system, the even distribution of the heat and the indirect heating system prevent this problem.
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.

The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.
We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:
It’s got built in manual controls, but there’s also the option to download an app to your phone so you can control your smoker through your wifi! Honestly, this really impressed me, and I don’t know why other manufacturers aren’t all over this. Apparently there’s a cloud based app coming out soon so you can control your grill anywhere you can get internet, so you could be sitting at your kids football game whilst checking the status of your post-victory feast! The controls are also fully programmable, so you could for example set it to smoke for 5 hours and then cook for 2, finishing just as you pull up onto your drive.
Yeah it seems like no one is providing any input on it…I was interested in having them review it and do a direct comparison to some of these other grills. I made the mistake of getting a Myron Mixon pitmaster Q3 at sears. It turned out to be a waste of money and the slight humidity I had caused the pellets to burst and seize up the Auger. Anyway I had narrowed my search down to a rec tech or silverback but none of the reviewers seems to be giving it any attention.
Whether it's smoking a rack of ribs or grilling a wood-fired pizza, to even baking a homemade apple pie, do it all with Traeger's 6-in-1 versatility. No matter what you grill, smoke, bake, roast, braise, or BBQ, it all gets flavored with amazing Traeger wood-fired taste. Don't settle for a grill that can only grill or smoke when you can do it all with a Traeger.

I bought my Traeger Pro Grill a year ago and have thoroughly enjoyed using it. The problems began when it suddenly stopped working. The warranty is a self-service warranty which means you have to service it yourself or load it up and haul it to a distributor for repair should your efforts fail. For this reason I HIGHLY RECOMMEND YOU AVOID BUYING A TRAEGER GRILL. Anytime you pay 1500 for anything a warranty should mean just that, it’s a replacement warranty. I am terribly disappointed with the response from Traeger. Please feel free to contact me should you need further clarification.

The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
Another avenue that many pellet grill owners use is participating in a bulk buy of their favorite brand.  Many times by ordering as little as a thousand pounds of pellets and having them shipped via pallet can save enough per pound to be worth the effort.  Also, check the websites of the pellet brands listed above, many have local distributors that maybe with an hour drive of your location.  If you are new to the pellet world, the thought of ordering a thousand pounds of pellets may sound excessive or intimidating.  Many felt this way at first, but if you are in a location where it is hard to get pellets, the mantra of keeping at least a hundred pounds of pellets (five 20 pound bags) on hand at all times starts to make sense quickly.
While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.
Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.
With the Camp Chef PG24S, you won’t have to constantly refill your hopper. Your pellets will be used as efficiently as possible, as this product comes with a hopper that can hold up to 18 pounds of wood pellets. With the digital heat control system, it instantly feeds the pellets into the grill to maintain the ideal cooking temperature. This ensures that food is cooked most satisfyingly.
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
We got one of these a few months back and are so happy with it! If you want a pellet grill but don't want to fork out hundreds of dollars for a Traeger.. Then this is the way to go. We have the smaller one and it's perfect for the two of us. But we have put a pork loin, 2 pans of bacon and 2 baked potatoes on at once and it all came out perfect. Baked potatoes on this grill are AWESOME. We love pork loins on it as well! We have yet to try hamburgers or something simple, as it turned winter here suddenly but it is great for what we have used it for!
You want your smoker to retain heat and to maintain a constant temperature. If you purchase something that’s inexpensive, yet made with a thin metal, you’re going to regret it because you’re going to be constantly fighting with the temperature. You could purchase the best smoker pellets, but if you don’t have a high quality smoker, it is all for not.
There have been some claims pellet grills are a safer barbecuing option.The claim is that pellet grillers by design do not allow as much of this potentially dangerous smoke to come into contact with the food. The fact that pellet grills don’t reach the same temperatures that other grillers do has also given rise to the idea that it is a safer barbecuing option.

It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.


The first thing you notice about yoders its the quality! They are testosterone, precision, heavy duty machines. Yoders cut the learning curve from novice to celebrated cook in less than a year, because they allow you to focus on the cooking instead of tending the fire which can take you lots of time. The only issue I have with mine is that the fan vibrates inside making a wierd noise, so I have to open the cooker and re-atach or re-instal the velcro strap that keeps the fan from vibrating. If this works, I will return to edit my review to 5x3 stars. However, the support team sent me everything I need to conduct the process my self; no complains here.

Hi Dan, I had a Bradley some years ago and the quality of the smoke is somewhat comparable to that of a pellet unit. As I said in my earlier post, compressed sawdust does not create the wood flavor that permeates the meat— no matter what pellet you use. I recently bought a Lang reverse flow, and on my first cook the difference was spectacular. My nephew went to the trouble of adding a full size wood burning firebox to his pellet stove as an experiment. He piped the smoke from the firebox into the pellet unit while making some ribs and the results were obvious. The next day he was out looking for a new smoker. Wood burners are a lot of work compared to a pellet unit, as you say, so I understand your reluctance. Many like vertical units that burn charcoal with wood chunks. These units are much easier to manage than a stick burner and give good results. All I can say is that the first time you make BBQ in your backyard with a wood unit, you will know you made the right choice. There are many good BBQ forums that discuss these points. Good Queing to you.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
A: This may be considered the million-dollar question for many reasons. When it comes to a pellet grill, individuals have to clean it out a bit different than a regular grill because there are unique elements to clean. Many individuals recommend cleaning a grill after every use depending on the size. However, for larger grills, it is recommended to clean it after four or five bags of wood pellets. Now, what you do is vacuum out the ashtray. Some brands do have an automatic ashtray cleaner. If not, then you have to vacuum it out with a vacuum. Other aspects to clean include removing the grease drain pan, removing the porcelain grills, the heat baffle, and properly washing with warm water and a bit of soap. Most brands will have cleaning instructions in the guidelines.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂

In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.
Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
Normally you will get 1- 3 years of warranty for the top pellet smokers from different companies. Traeger will serve you with a 3-year warranty while Camp Chef will give you only 1 year of warranty. Considered this the safe period for your pellet grill, so take advantage. If you own a top quality smoker then you may need not to think of any replacement within 5 years of buying.
Maintenance is an issue. There are moving parts on these grills. Moving parts eventually break. There is an auger with a motor, and a fan with a motor. There are proprietary electronics systems on these babies. Augers clog. Motors burn out. Electronics have bugs or fail. Especially when exposed to rain, snow, hot, and cold. When they fail, will the manufacturer have a replacement part?
Loved the idea of a "pellet smoker" - less stress, delicious meat. Bought mine at Costco 1 year ago and have used it many times with mixed results, not exactly stress less. Last time using it the pellet hopper caught on fire, turns out the auger chamber is packed full of pellets and won't move. Attempted to open chamber to clear and with this model it is extremely difficult (with unit sold thru Costco - newer ones look easier...) so I called customer service hotline. Called different 4 times and talked with a different live person each time and was promised a call back to schedule an in house repair. Never received one call back so I tried to email and again never received a return email. I have no choice but to return smoker to Costco.
A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
×