Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!

Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
This review is just a repeat of many already submitted.  Got my Traeger Elite 34 this summer at a trade show.  It would not get up to temperature, wouldn't go about 360deg with food inside.  Empty it would hit 390 max.  Most of the 'infamous' Traeger recipes call for 400+.  If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover.  I called Traeger and they claimed their grills 'never do this'.  After reading dozens of reviews since, the truth is that they seem to 'usually do this'.  The big grilles just do not have enough BTUs to heat up properly.
Camp Chef Smoke ProDLX Pellet Grill:Stainless steel lid and handleElectronic auto-start ignitionDual LED temperature readout: inte...rnal cooking temps and internal food tempsEasily choose your smoke settings or desired temperatureAutomatic auger dispenses pellets as needed for improved smoker efficiencyStainless steel probe measures internal food temperatureBuilt in sensor gauge reads cooking temperatureIncluded warming rack provides additional space to cook your favorite foodsClean-out ash can makes clean up simpleLarge capacity pellet hopper means less filling, more smokingNew hopper clean out makes changing pellet flavors easier than everIncludes recipe ideas in manual SpecificationsGrilling Area Dimensions: 19.5" x 22"Smoking/Warming Rack Dimensions: 6" x 24"Total Rack Surface Area: 560 sq inHopper Capacity: 18 lbs of pelletsCooking Height: 32.5"Overall weight: 127 lbs read more
One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 
Need Help?  Have a question or comment?1-888-827-4223Email UsGet Exclusive Offers & Expert TipsJOINTerms of UsePrivacy PolicyInterest Based AdsFor U.S. Residents Only © 2018 Ace Hardware. Ace Hardware and the Ace Hardware logo are registered trademarks of Ace Hardware Corporation. All rights reserved. For screen reader problems with this website, please call 1-888-827-4223 or email CareCenter@acehardware.com.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
Even though Louisiana Grills is a very solid competitor, we would still recommend going for the Traeger pellet smokers because of some longterm quality issues with Louisiana Grills. Many customers complained about the electronics failing after a few years as well as developing rust on the grill grates. If you’re going to buy a pellet smoker you’d expect it to last for years to come. While the Traeger grill might cost slightly more, we think it’s a worthwhile investment to buy something that will hold up over time.

Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.

The Camp Chef Camp Table is the perfect companion to any table top stove or dutch oven. The camp table will hold two 14 inch dutch... ovens and provides extra preparation and serving space to keep your food up off the ground. Works great with the Mountain Series stoves from Camp Chef and is a great accessory piece to your free standing stove. Side shelves* (Model LS60P) can be added for even more space. read more

Ever since my visit(s) to All Things BBQ in Wichita, my heart has belonged to the Yoder Smokers. I had researched many comparable size smokers, and guess what - they really are not comparable. The smoker started first time, quickly, and heated up well. I did ribs as my first foray and they were as perfect as my meager talents could get them. The fact that this smoker weighs in at almost 360 pounds speaks volumes as to how well built and how heavy gauge the metal is( something severely lacking in most other smokers). I had the extra shelf put in and the cooking space is easily double what I had seen in other smokers about the same dimensions. Hats off to All Things BBQ for the high quality Yoder smokers they so proudly distribute!!
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more

Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
This Bayou Classic outdoor patio stove offers a This Bayou Classic outdoor patio stove offers a wide range of cooking options operating from a bare simmer to a full blast flame. This outdoor grilling alternative is portable enough to take around with you camping tailgating hanging out in the backyard and road tripping in your RV. Despite its ...  More + Product Details Close

The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Currently, online retailers only have to charge customers sales tax who are located in the same state as the business which takes the original order. Camp Chef main offices and warehouse facilities are located in Utah in addition to Washington State. Therefore, only customers who purchase items from us and are also located in Utah, Colorado, Massachusetts, Indiana, Pennsylvania, and Washington will be charged sales tax.

With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.

Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.

My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Bake, braise, grill, smoke, and sear – all of these cooking techniques can be fully experienced by just using one unit of backyard cooker! Yes, you can definitely do different kinds of cooking to your pork, beef, fish, pizza, or pie by just using the Camp Chef Smokepro STX Pellet Grill without burning charcoals and woods to start the cooking process.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
This Bayou Classic outdoor patio stove offers a This Bayou Classic outdoor patio stove offers a wide range of cooking options operating from a bare simmer to a full blast flame. This outdoor grilling alternative is portable enough to take around with you camping tailgating hanging out in the backyard and road tripping in your RV. Despite its ...  More + Product Details Close
Barbecuing and grilling meats to the perfect temperature, texture and doneness is a skill that is acquired over years and years of practice. There is a lot that goes into making a good BBQ than just good seasoning and fresh meat, and any pit master will agree. There are just so many aspects you have to learn how to control: the temperature, the smoke, the placement, the ratios and so on. But you are lucky that this is new of yesterdays.
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
This is the most important aspect you should look into when buying a new pellet grill. You always hear people saying that a product will cost more money if it’s built with better quality materials and that is absolutely true when it comes to pellet grills. Let’s start with the basics – the most common material that is used when producing a pellet grill is steel. There are many different types of steel from high-grade stainless steel to lower grades that aren’t as sturdy. Cheap pellet grills will be constructed of a decent grade of steel when creating the outer appearance so that it’s sharp to look at. However, the inner parts of the grill are made out of lower-grade metals. Do you see the problem here? Even though the grill may look aesthetically pleasing from the outside, these nice looks won’t make up for thelow-quality materials that are used inside. This can quickly lead to the inner components of the grill deteriorating and in need of replacements. This ultimately results in you spending additional money to replace these parts once they are no longer functional.

Bought my Texas Elite 34 Traeger pellet grill last summer at Oshkosh Fly-in. Received it and assembled it with no issues. Began using it and discovered it will not make temperatures above 375 deg F. Most of the Traeger recipes need 400+ deg, so this wouldn't work. Called Traeger. They started sending me replacement parts, first the combustion air fan, then the auger motor, then a digital temp controller. None of these new parts had any effect on the problem. I have probably called Traeger 10 times, finally getting a hold of a second level supervisor named Jessie. He decided to send me a whole burner module; pellet hopper, auger tube, burner bowl, fan, controller... everything in one assembly. I installed it and no improvement. I did a time vs temp test for them at their request. They finally agreed it wasn't working properly.
Loved the idea of a "pellet smoker" - less stress, delicious meat. Bought mine at Costco 1 year ago and have used it many times with mixed results, not exactly stress less. Last time using it the pellet hopper caught on fire, turns out the auger chamber is packed full of pellets and won't move. Attempted to open chamber to clear and with this model it is extremely difficult (with unit sold thru Costco - newer ones look easier...) so I called customer service hotline. Called different 4 times and talked with a different live person each time and was promised a call back to schedule an in house repair. Never received one call back so I tried to email and again never received a return email. I have no choice but to return smoker to Costco.
Make a wealth of delicious recipes while you're camping or tailgating with the help of this versatile 2-Piece Camp Chef Spatula Se...t. The blades are made of sturdy and durable stainless steel and the heavy-duty handles are contoured for ease of use. The pancake flipper in this cooking spatula set has a long surface for large pancakes and a rounded end for easy non-catch flipping. The turner/scraper is beveled for scraping the grill or griddle and cutting while cooking. In addition, each piece features a handy hanging hole that allows you to store without taking much space. This easy to care for set is ideal for use when camping, hunting or barbecuing and grilling in a backyard. read more
As you could probably guess from the name of these smokers, they run by burning wooden pellets. Typically, a pellet smoker comes with a hopper on the side where the pellets are added. When you turn on the smoker, pellets will move from a hopper to a burn pot where they will be burned and the smoke will be diffused by a fan. A thermostat measures the temperature of the grill and determines how many pellets to burn while keeping a consistent temperature.
While the exterior is certainly whimsical, this smoker is serious business, with a proprietary Digital Pro Controller that maintains even cooking temperature, just like an oven. Dual meat probes let you monitor the pork and the chicken at the same time, and 425 square inches of grilling space means you can easily feed a crowd. The 11.5-pound hopper holds plenty of pellets, so you won’t need to refill for many hours.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.
There is no party like a backyard grill and BBQ party on a hot summer weekend with some good music on the back, and of course the centerpiece: the food. You see, food is a universal language. It is a way to say how much you appreciate and care for one another; a way to people’s hearts. And there is nothing more comfortable, warm and heart than some good old open grill and BBQ cooking on your pellet grill. And this is the reason you need an expert pellet grill review. 
Pellet grills are every lazy man’s dream appliance. These grills need absolute zero to minimal maintenance. You just need to lightly wipe through it after every use, and maybe thoroughly clean it 2 to 3 times a year! All pellet grills now come with a drip pan that catch the accumulating oils that drops from the food. They are also made with good quality raw materials that enable them to withstand the outdoor atmospheres all year round. If this does not entice your lazy bones, no other appliance will, and that is a fact. Period!

While there's not a lot to dislike about pellet smokers, it really comes down to your cooking/grilling style.  Some Smoking Geeks prefer pellet smokers to traditional smokers (or even the Green Egg style smokers) testifying that flavor is superior to that of other styles of smokers within the price range – and it's hard to argue with them.   While Traeger is the pioneer, there are other brands that give it a run for its money.
Well built and compact, this smoker and grill still has a 300 square inch cooking space, and is generally big enough to fit a small turkey inside, so it’s ample for six to eight people. It’s really easy to use, with an automated electric start, front mounted thermometer and idiot proof digital controls that make this so simple, an absolute beginner could walk up to it, have a quick play around and start cooking.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
PID controllers: PID controllers are considered by many to be the gold standard of grill controllers. Using complex algorithms, temperatures are accurate to within a few degrees. The pellet feed is constantly adjusted to maintain the correct temperature, and this type of controller can even accommodate programmable meat probes that work in tandem with the controller to lower the temperature when the meat is done. They also feature LCD and one touch buttons.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
It is different with REC TEC Wood Pellet Grill, here the solid construction is made of high quality materials. On the outside, high temperature powder coat and porcelain enamel finish. While inside, the manufacturers use stainless steel of very good quality for all the major parts. On the official website, we can read that you can find over 40 pounds of 304 stainless steel parts in this grill ( see for yourself ).

4. Temperatures were constantly all over the place. For example, on 70-80 degree days I learned to set my controller at 180 if I wanted to cook at 225-230. It was not uncommon to see temperature swings of +/- 30 degrees. Some Traeger users will tell you "yeah but did you play with the p-settings?" Why? Why would I want to have to constantly adjust a setting to make it hold a temp within +/- 5 degrees. Let's be honest. Most people want to set it and forget it. I fall into that category. This particular problem was so frustrating I went and bought an igrill 2 to monitor the internal smoker temp. As a note to this, I also bought 3 different brand controllers to try and remedy this problem with no success. Beyond frustrating!!
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.

Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)


Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised. 

I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
The control panel is simple, uncomplicated and easy to use, no codes of crazy steps to remember. Turn the switch on, set the temp once it lights and you are ready to go. On the outside the controls may look simple but behind the scenes it is working to constantly monitor feed rates and temperatures to lock into your set temperature as close as possible. The longer you cook the smaller the adjustments , making this one of he most consistent cookers on the market.
I love the taste of smoked food. I have now tried, ribs, turkey, chicken, and steak on my traeger grill and would have given them one star if not that smoked meat taste great. Everytime i use the grill, something that isn't supposed to happen, happens. I have to go out and check the pellet hopper every half hour to make sure it doesn't just use the pellets in the middle, so I have yo mix them around. Even when I do that, I can have the grill set for 225 and it goes up to 400-500 degrees or catches fire. Then when I restart it, it sometimes cools down to below 150° and shuts down in the middle of my smoke. I'm very dissappointed because the grill was not cheap, the pellets aren't cheap, and the food I am.ruining isn't cheap. I know traeger isn't going to do anything about it because I have called and they gave me "reasons" all of these things happen, and they already got their money from me but I am hoping I can deter as many people as possible from overspending on a defective grill. I really do wish it was a good product because I don't have the money to buy another.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
As the last criteria that we took into consideration, we have shared this a couple of times but we really wanted to focus on variety. We not only wanted to share some of the best tops of the line brands in the industry but we also wanted to share brands that may be unknown but offer excellent craftsmanship and material design. For instance, some of the grills we have shared are perfectly designed for everyday use, while some are designed for large events and parties.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.
Camp Chef has already been mentioned several times on this list. It's a venerable company that makes up in quality what it lacks in the name recognition of a Traeger or Weber. Their Deluxe Pellet Grill is built to reach and hold ideal temperatures for smoking. An internal system syncs pellet delivery to temperature instead of simply feeding in fuel when it begins to run out. This ensures a clean, consistent cooking experience. A removable ash can makes clean-up a snap as well.
Create delicious meals with ease with the help of the Camp Chef Griddle (FG-16). It is made out of durable heavy-gauge steel that ...will last for years. The surface measures 14" by 16". This polished steel griddle comes with slightly inclined sides for less mess and it has a convenient carry handle in front that makes for easy transport. This item covers one burner and fits many stoves. read more
The Yoder YS640 is a more professional pellet smoker which maintains consistent temperature across the cooking grates. This means that you will never have to move your food to avoid overcooking because of the hot spots within the smoker. In addition, cold weather and winds won’t affect the temperature within this smoker as they do with some other pellet smokers.

What are your thoughts about the Kalamazoo hybrid grills? From what I’ve found online, you have the choice of gas, charcoal and wood for cooking or combinations of all. I have no first hand experience with Kalamazoo but it seems very versatile? At the moment after a month of researching, I’m leaning towards a Mac/Yoder or a Webber spirit & egg or a Memphis….so in other words, I’m no closer to a decision than when I started. I currently have a 9 yr old treager that won’t break, seriously, I’ve only repainted once with rustolium….dang thing won’t break so I can get a new toy. I sear in a skillet in the kitchen. My treager has the smoke/med/high switch and I want more control, I’ve maxed what I can do and it’s a challenge in cold weather and wind but it was a great start when they were made to last, more than got my money’s worth. I cook at all levels from smoking to grilling. I do love pellets and don’t want an egg but enjoy the food as much as the process of preparing it. Ok probably to much info but money aside, will you list your recommendations of what you think is best for me?
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
First one, had an auger problem... told that this never happens. Returned to Costco, now on 2nd Unit. FIRE HAZARD, fire pot overloaded after temp dropped from 375 to 100 on a four-hour turkey. When I opened the lid to see what was going on it EXPLODED into a fireball and then had flames shooting out from all sides of the grill. There was even smoke and heat felt from the firebox side of the grill and it looked as though the overloaded firepot was burning into the auger line as well. DANGEROUS PRODUCT!!!
I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.
You want to easily switch to different smoky flavors: Changing flavors in your Traeger grill is as easy as changing the pellets that you place in the hopper. Through its website, Traeger offers several different smoky flavors of hardwood pellet offerings, including hickory, mesquite, apple, maple, cherry, and oak. And Traeger’s website provides information on which types of hardwoods provide the best smoky flavor for certain types of foods, which can help you successfully use this grill immediately out of the box.
****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
I didn’t actually learn to cook—at all—until after college. So my parents, who I now see only once a year or so because they live in France, have never really gotten a chance to try my food. One of the first nights after they flew over to see our home, I cooked them perfect lobster tails on the grill. When a long-lost cousin showed up one day during their visit, I ran to the store, bought two chickens, threw them on the Traeger, and we had a feast. Everyone agreed that those chickens were the moistest and most evenly-cooked they’d ever had. 

The construction and the elements - REC TEC  Pellet grill are an investment for years, safe from corroding. Most of competitive  grills look pretty on the outside and the manufacturers claim they are made of stainless steel. The truth is, only the outside part of the grill is stainless. The steel on the inside is different, and major parts are made of materials of poorer quality.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
The Camp Chef Italia Pizza has all the tools you will need to make you feel like a professional pizza chef. The artisan pizza kit ...includes two pizza peels to move your pizza from the counter to the oven and vice versus. Your pizza will slide right into the pizza oven or stone with ease just like a true artisan. Made of eco-friendly, renewable bamboo. Do not wash in the dishwasher. Dimensions: 11.75 Inch x 19.25 Inch x 0.35 Inch. Weight: 1.3 lbs. read more
Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.

First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!

When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
This Bayou Classic outdoor patio stove offers a This Bayou Classic outdoor patio stove offers a wide range of cooking options operating from a bare simmer to a full blast flame. This outdoor grilling alternative is portable enough to take around with you camping tailgating hanging out in the backyard and road tripping in your RV. Despite its ...  More + Product Details Close
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here. 
×