The temperature control unit is easy to use and relatively good. To start it, all you have to do is push one button.When it comes to the unit itself, the REC TEC RT 680 is, in general, thick and well built. Unfortunately, the reported temperature can differ from the actual temperature due to airflow inconsistencies inside the cooking chamber. The maximum temperature this grill can reach is 500°F.
I had hung my hat on the Yoder and had even contacted the factory and a couple of distributors in the DFW area. Then I did my usual, search craigslist and see if anyone is moving and selling their unit. Low and behold a Memphis Pro!!! Story was brand new, bought for a built in and now cannot use it now. Brand new but you may not have a warranty though. Price… wait for it! $1600!!! You got to be kidding! Scam?? Ok well I will contact him. Surprisingly he had it advertised for a few weeks and only had a few contacts but none serious. Ok, I will come look and if you can plug it in and show me the controller works I will take it. Called the factory and they were quite responsive. They said we probably won’t warranty the controller because we don’t know the history but it will depend on the failure. Everything else we will cover. So right before Thanksgiving headed to Dallas and it basically all looked brand new, plugged in and it did everything you could do without burning pellets.

Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task? 

Pellet meat smokers combine the features off all the other types of smokers. They have some electronics, such as the dial for setting the temperature, which means that they also require electricity. The flavor of the food will be similar to that of the charcoal smokers while keeping the convenience of an electric smoker – meaning you can set it and then forget it. The only thing you have to do is to make sure the smoker doesn’t run out of wood pellets.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Create delicious meals with ease with the help of the Camp Chef Griddle (FG-16). It is made out of durable heavy-gauge steel that ...will last for years. The surface measures 14" by 16". This polished steel griddle comes with slightly inclined sides for less mess and it has a convenient carry handle in front that makes for easy transport. This item covers one burner and fits many stoves. read more

To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so. 

With the Yoder YS 640 you won’t have to worry about scooping the ashes anymore. This pellet smoker burns the pellets so efficiently that there will be almost nothing left to clean. All you will have to do is empty the ash tray every now and then and wipe down the grates. You can spray the grates with PAM prior to use which makes clean up even easier.
Simply browse the product categories that interest you. Once you've located an item to order, click on the "Add to Cart " button. You'll immediately be taken to the "View Cart" screen where you can verify the item you have selected, remove the item or adjust quantities. From the view cart screen you can either continue shopping and select additional items or checkout.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
And of course, it’s definitely a plus when the company that makes your grill includes a multi-year warranty and top notch customer service. Pellet grills are finicky compared to gas or charcoal grills simply because there are so many more parts that require electronics or that have electrical components… which means there is a fair bit more that can actually go wrong or require service at some point.

Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.

One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
My experience with the seller has not been as pleasant. The Amazon product page indicates these are sold by Outdoor Cooking. Outdoor Cooking is listed on the Camp Chef website as an online sales partner. My order was not fulfilled by Outdoor Cooking, it was fulfilled by "deguns" (2.5 stars). I received my grill via UPS. The box was in rough shape, but still intact. The grill itself had some minor damge. I sent a message to the seller thru Amazon. Their response was basically, contact Camp Chef, if you have any issues we can contact them also. Not really the kind of response I was expecting.
For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
Camp Chef is proud to expand it's tradition of creating the finest cast iron cooking products with the introduction of the 12 Inch... diameter deep Dutch oven. What does that mean? It means that the most popular Dutch oven size can now feed even more people, cook a standing rib roast or bake the largest cobbler you've ever seen. We use the same tried-and-true methods from the other ovens in the classic line. True-seasoned cast iron comes ready to cook right out of the box. Even wall thickness, large carry bail and superior quality control is what separates this oven from all the other out there. If you a black-pot junky or just beginning this is the one that will quickly become a favorite. This Dutch features three legs, a handled lid and bale. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood.Total Weight = 25 lbs.Depth: 5 InchCapacity: 8 QT.OD = 12 3/8 InchModel No: SDO12DUPC Code: 033246209418 read more

REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).


In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
Entertaining a large group of people at the barbeque party becomes easy with the Camp Chef Yukon YK60LW 2-Burner Stove. With a coo...king surface of 448 square inches, this camp stove makes it convenient for you to cook for a large or small group of people. This Camp Chef two-burner range stove has removable legs to make for convenient portability - take it along for your camping trips or simply use it for your other outdoor cooking needs. Appliance-style control knobs let you have complete control over the flame, whereas the 3-sided wind screen helps protect the flame from wind. This portable camp stove also comes with a hose and regulator for added convenience. read more
Vista Outdoor is a leading global designer, manufacturer and marketer of consumer products in the growing outdoor sports and recreation markets. The company operates in two segments, Shooting Sports and Outdoor Products, and has a portfolio of well-recognized brands that provides consumers with a wide range of performance-driven, high-quality and innovative products for individual outdoor recreational pursuits. Vista Outdoor products are sold at leading retailers and distributors across North America and worldwide. Vista Outdoor is headquartered in Utah and has manufacturing operations and facilities in 13 U.S. States, Canada, Mexico and Puerto Rico along with international customer service, sales and sourcing operations in Asia, Australia, Canada, Europe and New Zealand. For news and information, visit www.vistaoutdoor.com or follow us on Twitter @VistaOutdoorInc and Facebook at www.facebook.com/vistaoutdoor.

PID Controller – one of the best controllers. Precisely maintains the temperature you set at intervals of +/- 5 degrees. Perfect when it comes to long and slow meat smoking at low temperatures. You can leave such a pellet grill for the entire day without worries and forget about it. When coming back after many hours, you’re sure that your meat has been cooked at the fixed temperature that you set.
You want a set-it-and-forget-it option: Traeger grills work best when they’re allowed to cook and smoke the food over long periods of time. As long as the system has fresh wood pellets in the hopper to feed the fire box, it will be able to maintain a steady temperature. So you can set up the grill and then leave it for half an hour, a couple of hours, or even longer, something that’s difficult to do with other grilling systems.
Main Problem (Product): Main Barrel arrived damaged (bent inward on one end where the open area is located), and the replacement was sent a month and a half later since my purchase. Its an 80 lb. box, with little padding, and all of the components are placed loosely in the barrel. The small tack welds inside for the trip tray arrived broken. (One person struggles with this big heavy box) They would do better by placing more cushion for shipping.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.

For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase.
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
Serve guests buffet style from your outdoor kitchen Serve guests buffet style from your outdoor kitchen with this stainless steel Cal Flame 12 in. Drop-In BBQ Food Warmer. Three generously sized compartments keep favorite foods hot and ready to eat. Each compartment has an individual cover to contain heat while serving. Constructed of 430-Grade stainless steel for years ...  More + Product Details Close
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.

A portable offering from Green Mountain Grills, the Davy Crocket is the most affordable pellet grill on our list, and the only one with WiFi capability. It’s compact, weighs only 57 pounds, and has folding legs so you can pack it up and bring it camping, tailgating, or to the beach. That’s something you can’t do with the Traeger Pro 22, and something we’re really excited about.


So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
×