Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
This is obviously no revelations that temperature is the first on my list. When it comes to cooking appliances, temperature is always a key factor. However, it is not the sole reason to be on my list. The thing about temperature you need to look for in a good pellet grill is its ability to control, change and maintain it. Any grill can turn screaming hot, but only the best ones provide you with multiple temperature settings, and are able to maintain it constantly to ensure an even cooking surface where it is not too hot on the left and cold on the right. Many pellets come with special, even patented, temperature features.
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
Fans of gadgets – More expensive models come with very interesting features. You can download app for your phone or tablet (iOS and Android). Then you can use Wi-Fi to connect with your pellet grill. It allows you to monitor the temperature inside the grill while away from it. Some of the grills even make it possible to check the internal temperature of the meat.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.
Pit Boss Wood Pellet Grills are fueled by all natural BBQ wood pellets. The digital control board ignites the grill and allows you to set the cooking temperature from 180° to 500°F. Fan forced convection cooking eliminates the need for a rotisserie and creates a versatile environment for grilling, roasting, smoking, braising, searing and baking. The 820 features a Flame Broiler as standard; this adds the option to grill directly over an open flame when direct heat is needed. The Pit Boss 820 features a large 820 sq. in. total cooking surface: 580 sq. in. main and 240 sq. in. removable upper rack. With complete structural strength and durability, the Pit Boss 820 is made to last.
I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.
This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one.
Barbecuing is supposed to be hard. It should involve chopping wood, breathing in charcoal dust, and hours upon hours to keep a constant temperature from your grill. A pit master would never subscribe to the “leave it and forget it” philosophy that a pellet smoker brings to the table, right? The best pellet smoker reviews show that this isn’t necessarily the case.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born from love of crisp brick-oven style pizza. It’s been designed with the cooking ability of professional brick ovens but with the accessibility ease and size of a portable grill. Whether you’re holding an impromptu family pizza night inviting the friends over for ... More + Product Details Close
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
RT 700 offers a Front Folding Shelf and has its own set of meat probe to monitor meat temperature while the grill smoke is infusing with the meat. Its Stainless Steel body protects it from rust and the colors from cracking or peeling. With its built-in WiFi-enabled control, coupled with Rec Tec’s proprietary PID algorithm, you will have control over your cooking process remotely using your wireless devices.
Just finished my first smoke on the YS640, ribs and chicken thighs. This machine is amazing. It couldn't be simpler to use. The chicken was the best I have ever tasted. The ATBBQ team was great, with fast shipping and they threw in some extras. I could not be happier and can't wait for years of great food off the YS640. Don't hesitate to buy this cooker or to order from ATBBQ.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
After 10 days of not seeing anything in my email I called them. They told me they had no order. After two weeks and more phone calls then a grill finally shows up but without the cover or the pallets which I paid for and was on the order. Three calls into managers and customer service still not resolved. When I threaten to take the grill back to Costco I was told to go ahead and have a nice day.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
This grill produces fall off the bone ribs. I've also cooked a brisket to perfection. My only issue is that I have to clean it after every use. If it isn't cleaned properly (I remove all of the grates and use a shop vac to suction all ashes and unburned pellets) the pellets will back up and when they finally push through, you will have a huge flare up that will potentially burn whatever you are cooking as well as take the paint off the grill itself. Also, I find it works better if you set the dial to OFF and then back to whatever temperature you want. Other than those few quirks, I love this grill. I did find a larger Pit Boss after I bought this one, but it was about $150 more.
****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
While the Green Mountain Grills Davy Crockett Pellet Grill is compatible with most iOS and Android devices, I want to stress, check the compatibility of your device with the grill before purchasing because it would suck to buy this grill only to find out that this feature is not compatible. Also, if you do not plan on using the grill on some elevated surface, the legs are not tall so the grill sits close to the ground. Regardless, this is a GREAT smoker: your meat will come out tender and juicy with that authentic BBQ taste we all love! Neither of these cons affects the quality of your BBQ and both can be worked around.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)
When it comes to buying a new pellet grill, do yourself a favor and conduct some serious research on the grills you are looking to purchase before jumping into it. Just because a pellet grill looks sharp on the outside and has a cheap price tag to go along with it, doesn’t necessarily mean you’ll have spent less money over the course of three or four years compared to buying a well-built pellet grill with a good warranty.
Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..
Our first visitor at the the house was my future mother-in-law. She’s a vegetarian, so I cooked vegetable-based meals during her visit. I’m a meat guy, so beyond side dishes, I don’t really have a repertoire of veggie dinners. I'd see what the local co-op had in stock that day, then Google the ingredient, plus the word Traeger, to find a recipe. And voila: perfect grilled portobello mushrooms and stuffed peppers.
Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
We have shifted to a new house and here we have a very nice backyard. We were thinking of having pellet grill for the backyard for friends and family gatherings for making our holidays memorable. According to your review I think Camp Chef SmokePro DLX Wood Pellet Grill and Smoker | PG24B will be a good option for us. Do you have any other suggestion for us as it will be our first and we don’t have much knowledge about it.
As you could probably guess from the name of these smokers, they run by burning wooden pellets. Typically, a pellet smoker comes with a hopper on the side where the pellets are added. When you turn on the smoker, pellets will move from a hopper to a burn pot where they will be burned and the smoke will be diffused by a fan. A thermostat measures the temperature of the grill and determines how many pellets to burn while keeping a consistent temperature.