To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Camp Chef Smoke ProDLX Pellet Grill:Stainless steel lid and handleElectronic auto-start ignitionDual LED temperature readout: inte...rnal cooking temps and internal food tempsEasily choose your smoke settings or desired temperatureAutomatic auger dispenses pellets as needed for improved smoker efficiencyStainless steel probe measures internal food temperatureBuilt in sensor gauge reads cooking temperatureIncluded warming rack provides additional space to cook your favorite foodsClean-out ash can makes clean up simpleLarge capacity pellet hopper means less filling, more smokingNew hopper clean out makes changing pellet flavors easier than everIncludes recipe ideas in manual SpecificationsGrilling Area Dimensions: 19.5" x 22"Smoking/Warming Rack Dimensions: 6" x 24"Total Rack Surface Area: 560 sq inHopper Capacity: 18 lbs of pelletsCooking Height: 32.5"Overall weight: 127 lbs read more
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Temperature: Most of all, you have to pay attention to whether your pellet grill maintains a chosen temperature. People buy a pellet smoker because it makes it possible to smoke meat for long at fixed low temperatures. Very convenient and simple, and a grill that always maintains a selected temperature guarantees that the meat will be perfectly cooked.
Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?

They had the field to themselves for a few years, but the idea was too good to go unimitated, and with the digital age came the electronic controller that allowed Traegers and others to create a system that had a thermostat in the cooking chamber that would tell the fan and auger when to do their thing. Today there are more than a dozen manufacturers making increasingly sophisticated machines.
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.
Right off the bat I could tell this smoker was made in America! While putting it together the holes actually matched up! ATBBQ- beat the 5-6 week lead time and delivered in two weeks out to California. This thing is a beast- the heavy weight I was looking for in a smoker and it has the most consistent temp I have ever had with a pellet grill. I messed up on the first pellet grill that starts with a "T" and should have started out with the Yoder YS640. If you are on the fence or wondering if it's truly worth the cash. All I can say is yes...YES it is. Pull the trigger and order this now- you won't be disappointed. I don't work for Yoder or ATBBQ- I'm just a experienced BBQ'r that could not be happier! Thanks Yoder and ATBBQ,

Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
Of course, there are always bargain hunters. Some might say “Why pay $2000 for a pellet smoker and then bargain hunt for your pellets?” but if you think about it this way — isn’t it like cooking with varying qualities of charcoal? Sometimes an inexpensive, less efficient pellet blend might be just fine for burgers or chicken breasts. Other times, you may want to step it up with a premium flavored pellet where whole turkeys, prime rib roasts, or a nice brisket can really shine.
As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.
Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
Pellet grill uses various types of flavored wood pellets to flavor the food by infusing smoke into it. Pellets of numerous flavors are available on the market:  hickory, strawberry, oak and olive are just to name a few. Many pellet grill companies also manufacture wood pellets alongside the pellet grills that go hand in hand with their respective grills. So know your options, and be sure to spend a few extra bucks into buying a good quality wood pellet for your pellet grill as this is what will set apart your smoked exotic BBQ from the mainstream flavors out there.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.

Even though Louisiana Grills is a very solid competitor, we would still recommend going for the Traeger pellet smokers because of some longterm quality issues with Louisiana Grills. Many customers complained about the electronics failing after a few years as well as developing rust on the grill grates. If you’re going to buy a pellet smoker you’d expect it to last for years to come. While the Traeger grill might cost slightly more, we think it’s a worthwhile investment to buy something that will hold up over time.
Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.

Just like many other appliances available, the Davy Crockett pellet grill comes with Wi-Fi. It may seem absurd to pay more only because of the Wi-Fi feature, but every experienced outdoor griller will tell you that it can come in handy. If you want perfectly grilled or smoked food, you will need to keep your eyes on the temperature of the grill all the time. Taking your eyes off the thermometer for even a few seconds can result in your food being burnt. Because of this, the person behind the grill doesn’t get a chance to hang out with the rest.
I have found that using the upper shelf gets more airflow around the meat than the lower shelf. I asked the AmazingRibs.com science advisor Prof. Greg Blonder about the problem (he has a MAK 1 Star). He explained that smoke sticks to cool surfaces and wet surfaces, and the surface of meat warms and dries out after a few hours. When he wants more smoke flavor he uses a strong smoke wood like hickory or mesquite, he starts with cold meat, and then he keeps the meat moist by painting or misting it with apple juice or a mop like Lexington Dip or East Carolina Mop or Texas Mop Sauce. A awter pan can help because the water condenses on the cool meat and attracts smoke. Read his detailed research on the subject in my article on the Science of Wood and my article on Basting.

Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
Perfect for the simple lifting and placing of pizzas and breads to and from the oven. Long, ergonomically designed handle makes ha...ndling food effortless. Durable stainless steel construction. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more

In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
Due to having such features and being the best Lousiana Grills Product, the Louisiana Grills LG Pellet Grill 1100 could not escape our vigilant gaze when we did our research. However, it had some shortcomings, mainly due to its build and price that did not allow it to make it into our pellet smoker review. Regardless, we could compare it with some of our products that it had tied with. But as always, we could only choose the top 10 products for this review and this had to go. Regardless, this still is a great product, worth mentioning.
So if you want more of a smoke profile, cook at longer and lower temps in your pellet pit. I have found that is the best way to get a more distinct smoke profile in your food. Cook at 180–190 for the first several hours. That probably has the biggest impact. Next, make sure you are using a good, quality hardwood pellet. I can tell you that you will notice a very large difference in the flavor profile between say a Traeger pellet vs. say one of Candy’s [BBQers Delight pellets]. — Read more on PelletSmoking.com
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
If you’re looking for very portable smoker on a budget, we recommend the Davy Crockett by Green Mountain Grills. However, if you’re looking for a small backyard smoker that you can use at the occasional picnic, tailgate, or cul-de-sac party, we recommend the Traeger Tailgater. We think the slight increase in cost is justified by the bigger grill space, which comes in handy if you’re using your smoker frequently or to cook for more than two people.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.

I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.


The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
There’s so much about this grill to love, but one aspect that gets RAVE reviews is the customer service. Rec Tec has pretty much the best customer service in the industry. First off, there’s a 6 year warranty, meaning, they expect their product to perform. But in the unlikely case that you have issues, their customer service is incredibly fast to respond, is available even on the weekends, and believe it or not, the owners even provide their cell phone numbers so they can help you through a problem when you’re stuck. Incredible!
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
Pellet grills made out of stainless steel are more durable and rust-resistant and are often the most attractive option. Since many smokers are painted, make sure to research the quality of the paint. A high-temperature powder coat paint can withstand high heat. This is important because if the paint flakes it will leave the steel exposed to outside influences and it could rust.

One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
Three and a half months ago, my fiancée and I loaded all our worldly belongings into a trailer and drove that stuff to our new house in Montana. As one of my most-loved things, the Egg was in there, carefully packed inside and out to make sure no part of it would break. Worrying about it riding back there was one of the reasons my average speed on that drive was just 47 miles per hour. 
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!

The Camp Chef Italia Pizza has all the tools you will need to make you feel like a professional pizza chef. The artisan pizza kit ...includes two pizza peels to move your pizza from the counter to the oven and vice versus. Your pizza will slide right into the pizza oven or stone with ease just like a true artisan. Made of eco-friendly, renewable bamboo. Do not wash in the dishwasher. Dimensions: 11.75 Inch x 19.25 Inch x 0.35 Inch. Weight: 1.3 lbs. read more
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.

However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.


Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.

Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.


This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.

Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.

One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.


If you’re in the market to buy a grill, yet you’ve only grilled with propane or charcoal in the past, wood pellet grills may have piqued your curiosity. These grills use a very different cooking method than the direct flame of propane, resulting in more even heating and more precise temperature control. A wood pellet grill is more like a smoker than an open flame grill, as it’s difficult to sear meat with a wood pellet grill. Purchasing and using a wood pellet grill is going to be more expensive than propane and charcoal grills.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?

Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.
Download an iOS or Android app and connect using WI-FI. The app enables to do many different things such as remote control of the grill temperature, control of temperature inside the meat or the ability to check the amount of pellets inside the hopper. You can get the temperature higher or lower while away from the grill. You can learn more about how this function works on the manufacturer’s official website.
Is it food quality? All of my foods are the best I have ever grilled. The ribs are nearly falling off of the bone, yet still moist! In the past, if I tried to get them to that point, they would have been very dry. All of my meats have been moist with a lightly smoked flavor. My breads perfectly crusted on the outside, moist inside with a perfect crust!
Hey DS – You’re dead on correct re: Grilling vs. Smoking. Most to nearly all Pellet Smokers are used as “smokers” in the truest sense. Louisiana Pellet Smokers boast a direct fire feature for grilling, as do Yoder smokers. However, I’m with you in that a grill is a grill and a smoker is a smoker. GMGs are very popular down here on the FBA circuit. However, most folks do find that they don’t produce the amount of smoke preferred for competition meats (which, in truth is a complaint about many pellet smokers). This is why stick burners and “some” gravity feds get a boost in rep among competition cook teams. That said, I do see folks happily using pellet smokers, and some win with them. One “trick” I see used now and again to boost the smoke output on a pellet smoker is to use one of those smoke tubes… like the A-maze-n Tube Smoker. Thanks for your comment, and for stopping by to read this blog post! – Kevin

Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!

PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.


Other elements of the grill are the legs, which come in varies designs and construction materials. The automatic ignition starter to start the fire as well as the digital controller where individuals can achieve up to six different cooking methods ranging from grilling to baking and smoking. With that said, one of the most important aspects that we highly recommend individuals to consider is a green with a grease bucket or an ash cleanout design that vents out all of the ash sediment from the grill.
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
Our Privacy Promise, Terms of Service, Code of Ethics. AmazingRibs.com promises to never sell or distribute any info about you individually without your express permission, and we promise not to, ahem, pepper you with email or make you eat spam. We are GDPR (the General Data Protection Regulations as passed by the European Union). GDPR requires that we be willing to delete any info we have about an EU resident if you request it. We go a step further. We extend this right to anyone, EU resident or not. For more about our privacy promise, code of ethics, terms of service, and how we operate to insure you unbiased info, click here.

My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
What we loved most is that it has a trap door to allow burn pot cleaning after every cooking. It lessened our job of cleaning this pellet smoker by 60%. It is more than amazing because from our research we know that a feature like this will cost twice as much as the Camp Chef. Honestly, this has emerged as our key point when we selected this smoker to be the best in our review.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
When it comes to spending your own hard-earned money on a new wood pellet grill, you want to invest in a product that is going to last you for a while. There are many differences between purchasing a cheap wood pellet grill and a pellet grill that is built with quality materials. Even though the cheaper grill may be easier on your wallet in the short run, the long-term costs will quickly outweigh the initial savings. So, if you’re thinking of buying a cheap pellet grill, continue reading to learn about the true costs that could be associated with your decision.
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
The Fast Eddy by Cookshack is an American designed and manufactured Pellet Grill with a riveted stainless steel body and solid digitally controlled system to maintain the consistent temperature. The name of the game here is sturdy reliability. What it lacks in little extras like wifi controls it makes up for inconsistency. Whether you're smoking, grilling, or searing, the Fast Eddy performs.

I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂

Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
Just like you need to have precise control over your unit’s temperature, you also need to make sure that your smoker can reach an adequate temperature. Most pellet smokers can reach temperatures between 180°F and 425°F, which is a decent range that can fulfill most of your smoking, baking, and grilling purposes. However, if you want to sear your meat, you will need a unit that can reach at least 500°F.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.

PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
×