Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.


I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
Many people misunderstand a pellet grill of consuming a large amount of power for its working. But it is not even remotely true. While it is true that a pellet grill will use up a good amount for power initially, but it only uses that to come to temperature and form. Once it is ready and in form, it power consumption drops so dramatically that some pellet grills use almost as little power as a light bulb; an ideal choice for keeping power costs to a minimum.

The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
Second, you’ll have to figure out what BBQ pellets you want to use. There are many different brands, blends, and mixes to choose from, and you’ll likely want to do some side by side testing to see what you like best on what meats. My very good friend and BBQ buddy Shane Draper really likes to make his own blends  – using different woods in different proportions depending on what he’s cooking.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).

So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side. 

This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.


Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.

Certain statements in this press release, including statements regarding the expected future financial performance of Camp Chef and the impact of that performance on Vista Outdoor, constitute forward-looking statements as defined in the Private Securities Litigation Reform Act of 1995. The words 'believe', 'expect', 'anticipate', 'intend', 'aim', 'should' and similar expressions are intended to identify such forward-looking statements. All such forward-looking statements involve estimates and assumptions and are subject to a number of risks and uncertainties, many of which are beyond Vista Outdoor's control, which could cause actual results to differ materially from the expectations described in the forward-looking statements. Among those risks and uncertainties are: assumptions regarding demand for Camp Chef's products; the risk that the anticipated benefits and cost savings from the transaction may not be fully realized or may take longer than expected to realize; the ability of Vista Outdoor to retain and hire key personnel and maintain relationships with customers, suppliers and other business partners of Camp Chef; costs or difficulties related to the integration of the business following completion of the transaction; and changes in the business, industry or economic conditions or competitive environment. Vista Outdoor undertakes no obligation to update any forward-looking statements. For further information on factors that could impact Vista Outdoor, and the statements contained herein, please refer to Vista Outdoor's most recent Annual Report on Form 10-K and any subsequent quarterly reports on Form 10-Q and current reports on Form 8-K filed with the U.S. Securities and Exchange Commission.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
At the end of the day, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet smokers use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.

Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.


The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

Smoking v. Grilling more about the temp you’re cooking at than how it’s heated. Smoking happens below 300F most of the time. The Sawtooth Pellet Grill can get to 550F-600F at the top end so it’s more of a grill at that point that smokes. I’ve grilled burgers and fajitas and other stuff like you would a gas grill. Works great and it’s made in the US!


Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.

Igniter: An igniting rod, heated up to a red hot level, ignites wood pellets as they fall inside the firebox. A cooling fan blows air into the pellet smoker from behind the pellet auger to prevent heat backdraft, while the fan underneath the firebox fans the flame – distributing heat evenly throughout the smoker. This heat is used to smoke and slow cook food in the smoker to give it the best flavors possible.
The ceramic stone promotes even heat distribution and the domed ceiling design mimics the same heating pattern as a wood fired bri...ck oven. Preheats in just 15 minutes, exceeding 600°F if needed. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
The grill is plated with beautiful stainless steel that gives the grill a refined and impressive look. The huge cooking area includes 570 square inches of surface area. That’s enough to hold 20 burgers or 4 rib racks! It also contains a second warming rack and bottom shelf that provides the grill stability and extra storage. This version comes with a sear box that can reach temperature of up to 900 degrees Fahrenheit, which caramelizes your food. There’s a cheaper version without a sear box that costs around $200 less if a sear box isn’t a necessity for you. Additionally, the legs are built with extreme thickness giving the grill a grounded base. The caster wheels add portability to the grill so you can find that perfect place in the backyard.
Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
Camp Chef is proud to expand it's tradition of creating the finest cast iron cooking products with the introduction of the 12 Inch... diameter deep Dutch oven. What does that mean? It means that the most popular Dutch oven size can now feed even more people, cook a standing rib roast or bake the largest cobbler you've ever seen. We use the same tried-and-true methods from the other ovens in the classic line. True-seasoned cast iron comes ready to cook right out of the box. Even wall thickness, large carry bail and superior quality control is what separates this oven from all the other out there. If you a black-pot junky or just beginning this is the one that will quickly become a favorite. This Dutch features three legs, a handled lid and bale. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood.Total Weight = 25 lbs.Depth: 5 InchCapacity: 8 QT.OD = 12 3/8 InchModel No: SDO12DUPC Code: 033246209418 read more
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
Ordered Renegade Pro, received it and missing 6 washers to assemble the legs. They are rattling around inside the unit making it unusable. The control knob also sheared off in shipping. Traeger has yet to come up with a solution to fix or replace the unit...disappointed in their customer service. They don't care about customers after they get their money.

To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.


The Smoke Pro SE Pellet Grill brings award-winning barbecue to your back patio. Simply select the desired cooking temperature and ...let the smoker do the rest. Our Smart Smoke Technology maintains a consistent temperature range to produce as much smoke as possible. That means the best flavor possible. And at the end of the cookout, you’ll enjoy the easiest, quickest cleanout system in the industry. Instead of dismantling and cleaning your grill after every use, you can pull a lever and empty the ash out of the fire pot. In a few seconds, you’re ready for your next big barbecue. And it’s good thing too, because that smoky taste is going to keep everyone coming back for more. read more
Bigger heavier hotter: own a world class BBQ Bigger heavier hotter: own a world class BBQ in your own backyard. The LG900 presents the same game-changing features as the LG700 integrated with a larger cooking surface. Perfect for larger families and social gatherings the LG900 bears an easy to clean 913 sq. in. cast iron cooking grid. Elevate ...  More + Product Details Close
Pellet grills come in many different sizes that accommodate food as per those sizes. However, even the smaller kinds are able to cook up a meal for a large family of 4 to 5 at a time! The larger ones are obviously able to accommodate large portions of meat and other food in it. In fact, some large pellet grills are used to cook up a whole baby lamb or large fishes at a time! This is one appliance that has been proven ideal for feeding a lot of heads at a time without the stress and the hard work of course, making it great for small to medium parties and get-together.
The best pellet grill smoker has the benefit of being easy to light and easy to use. With a pellet smoker, you put the pellets in the hopper, light the heating unit, and you don’t have to worry about it. Conversely, with a charcoal smoker, you have the struggle to light the charcoal, and then throughout the entire cooking time, you need to check the backup on the unit to make sure that it’s functioning properly.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.
We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."
This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
×