OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.
Pellet smokers heats up faster than charcoal grills, but slower than gas grills. It reaches satisfying temperatures of up to 500 degrees F ( with more expensive models it’s even up to 600 degrees F ), of course it’s much less than gas grills. But the upside is that pellet smoker can maintain low temperatures even at 160 degrees F for many hours. Some of the models are equipped with a gas powered sear box that heats up even up to 900 degrees F.
The built-in cords on outdoor cooking devices are often not long enough, and although regular household extension cords will work for rotisserie kits, they will not carry enough juice to keep you pellet smoker or electric smoker going. They could become a fire hazard as they heat up trying to deliver power to the unit. To extend the cord you need a large capacity cable as measured in amps. Here's how to figure out what you need:
Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
Other elements of the grill are the legs, which come in varies designs and construction materials. The automatic ignition starter to start the fire as well as the digital controller where individuals can achieve up to six different cooking methods ranging from grilling to baking and smoking. With that said, one of the most important aspects that we highly recommend individuals to consider is a green with a grease bucket or an ash cleanout design that vents out all of the ash sediment from the grill.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)

Each grill is porcelain coated, like you’d find on professional grills, for exceptional heat transfer and easy wipe cleaning. This attention to excellence is extended over the whole machine, with everything made out of heavy gauge steel and top quality material. The only real let down is the wheels, which are kind of low quality, but they’re real simple to switch out.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.

You want to easily switch to different smoky flavors: Changing flavors in your Traeger grill is as easy as changing the pellets that you place in the hopper. Through its website, Traeger offers several different smoky flavors of hardwood pellet offerings, including hickory, mesquite, apple, maple, cherry, and oak. And Traeger’s website provides information on which types of hardwoods provide the best smoky flavor for certain types of foods, which can help you successfully use this grill immediately out of the box.


First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.

I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
This presumably has the most exact temperature perusing of any grill right now available. Accompanying a cookbook, a simple get together, and a decent outline, the PG24 is definitely justified even despite the cash. I enjoyed the decision of a wood screw framework rather than a suction framework, since it spares cash on pellets, and manages temperature better. For those needing to get into pellet grilling, this would be an astounding decision.

“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.

The Universal Parts Premium Small Spaces Cover features The Universal Parts Premium Small Spaces Cover features a durable polyester fabric and weather resistant coating. The cover protects from weather conditions when the grill is not in use. Closure strips are designed for a secure attachment. This unit fits most electric patio grills.  More + Product Details Close
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.

Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.
At Grills Forever, we work hard to bring you the best product reviews possible through an extensive online research process. We go through countless online reviews and browse through different brands, both known and unknown. We then go through their features and the value they can provide to the users. We shortlist the top products to do physical testing and then come up with a review. We do this on a regular basis to keep our list up-to-date.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.
As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.
First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
The Fast Eddy's by Cookshack PG500 Pellet Smoker is a collaborative design from respected smoker manufacturer Cookshack and competition-barbecue-circuit pro "Fast Eddy" Maurin. The FEC (Fast Eddy's by Cookshack) line has been popular with competitive teams for years. While most FEC models have a utilitarian appearance, the beautifully crafted stainless steel PG500 fits right in with your shiny outdoor kitchen.

How much food are you going to smoke? This is important because some of the top pellet smokers are relatively large. And if you’re not looking at smoking a lot of meat, you might purchase a unit that’s too big. Conversely, if you buy a unit that’s too small, you are going to be frustrated because you’re going to make some delicious meat just not as much as you need.

If you’re in the market to buy a grill, yet you’ve only grilled with propane or charcoal in the past, wood pellet grills may have piqued your curiosity. These grills use a very different cooking method than the direct flame of propane, resulting in more even heating and more precise temperature control. A wood pellet grill is more like a smoker than an open flame grill, as it’s difficult to sear meat with a wood pellet grill. Purchasing and using a wood pellet grill is going to be more expensive than propane and charcoal grills.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Bigger heavier hotter: own a world class BBQ Bigger heavier hotter: own a world class BBQ in your own backyard. The LG900 presents the same game-changing features as the LG700 integrated with a larger cooking surface. Perfect for larger families and social gatherings the LG900 bears an easy to clean 913 sq. in. cast iron cooking grid. Elevate ...  More + Product Details Close
You aren’t limited to basic barbecuing. For us, what really stood out was its ability to deliver pro chef-level cooking even at home. This smoker lets you explore all there is about cooking, letting you braise, grill, smoke, bake, roast, braise and BBQ all kinds of food. Using only the best and the purest hardwood pellets, you’re sure to have the juiciest and tastiest meats and vegetables every time you host your outdoor parties. If you think you have to give up quality because of the quantity of foods it can cook, that’s not the case. Quality is maintained whatever it is you’re cooking.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.
So that brings me to the one thing I have learned in all this that I basically read when I was getting started. One of the biggest keys is “Temperature Control”! If you want consistent food make sure you get that under control. It is the key to solid consistent food! Once you get your food consistent you can experiment with a lot of other things. But if you can’t get that down, you will always be looking for another magic bullet. The number one magic is temperature!

I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.

Perfect for the simple lifting and placing of pizzas and breads to and from the oven. Long, ergonomically designed handle makes ha...ndling food effortless. Durable stainless steel construction. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more

In my experience, running Traeger pellets, the grill has functionally three temperature settings;  1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table.  2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs.  3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho. 

When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.

The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
Generally speaking cheap grills are not made with quality materials. While the outside may look good, often times you will find the guts of the grill are made with lower grade metals. This of course affects functionality and longevity. If the inside of the grill isn’t made using quality materials you will literally burn through it over a certain period time.

Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!

One of Yoder’s most unique features is the Variable Displacement Damper. This makes it easy to smoke, sear, and grill your food using the YS640. This is a metal plate that moves along the lower smoke box. If you move it all the way left, it concentrates heat directly over the firepot for conductive searing. If you move it back to the right, the heat will spread evenly across the entire some box for even cooking. The unit comes with a side firebox which has a removable cooking grate if you want to grill your food in it.


Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.
To see if ShippingPass is right for you, try a 30-day free trial. Also, with ShippingPass, there is no need to worry about commitment. If you decide you want to discontinue the service, you can cancel your subscription at any time. No matter what your shipping needs, Walmart's got you covered. Sign up for ShippingPass so you can shop more, save money and live better.

While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.
When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
I had hung my hat on the Yoder and had even contacted the factory and a couple of distributors in the DFW area. Then I did my usual, search craigslist and see if anyone is moving and selling their unit. Low and behold a Memphis Pro!!! Story was brand new, bought for a built in and now cannot use it now. Brand new but you may not have a warranty though. Price… wait for it! $1600!!! You got to be kidding! Scam?? Ok well I will contact him. Surprisingly he had it advertised for a few weeks and only had a few contacts but none serious. Ok, I will come look and if you can plug it in and show me the controller works I will take it. Called the factory and they were quite responsive. They said we probably won’t warranty the controller because we don’t know the history but it will depend on the failure. Everything else we will cover. So right before Thanksgiving headed to Dallas and it basically all looked brand new, plugged in and it did everything you could do without burning pellets.

Other elements of the grill are the legs, which come in varies designs and construction materials. The automatic ignition starter to start the fire as well as the digital controller where individuals can achieve up to six different cooking methods ranging from grilling to baking and smoking. With that said, one of the most important aspects that we highly recommend individuals to consider is a green with a grease bucket or an ash cleanout design that vents out all of the ash sediment from the grill.
As a conclusion, it’s a very good pellet smoker & grill. Main advantage is the sear box that runs on propane, allowing to reach temperatures of up to 900 degrees F. Definitely a very useful feature during cooking. Another interesting feature is Smart Smoke Technology, which allows to create much more smoke while maintaining the desired temperature.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
So what about the question of blends versus 100% pure species pellets?  Should you avoid blends?  Should you only use 100% pure?   That is a web to unweave and depends greatly on what you are cooking as to the correct answer.  Through our testing we found many blends to work very well.  We liked them so much that we incorporated them into what we offer.  Not all blends are created equal though and the amount of hardwood versus flavor wood varies widely across brands.  We also found that some 100% pure pellets such as cherry and apple had harder times reaching higher grilling temperatures and lacked the harder core flavor punch of hickory or mesquite.  Coming from the world of stick burners many new pellet grill owners assume that going 100% cherry or apple is going to work for them since that is what they have grown accustomed to.  At the end of the day, they end up moving to a pellet with a deeper flavor like hickory or mesquite to get the results they are used to.

At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.
With that being said, it’s necessary to understand how much wood pellet would last you and for how long. A 40-pound bag of wood pellets would last you for approximately 24 hours if burned at 250 F. Therefore, if you’re trying to slow-cook a large piece of brisket for 14 hours straight, your 6-9 lb hopper capacity just won’t cut it. You’re going to have to refill it in the middle if you wanted to continue cooking.
Now, for the good stuff: do not hesitate to spend an extra or even two bucks for a feature that you will use and appreciate. Consider your pellet grill as an investment, something you are going to buy, and be using and enjoying for years and years to come. Features like meat probes to check the internal temperature of foods are excellent for taking the guess work away from cooking meat to a particular doneness. You will never end up with an overcooked and rubbery, or undercooked and raw steak ever again! Features like smartly designed grills that consume and spread heat evenly are also great for cooking food to perfection without having to move it from side to side to find the right temperature spot.
Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.
What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
×