Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.

This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
This post was EXACTLY what i was looking for! Have been longing for the ability to make the gooey delicate saucy brisket that we get out here at the chain Armadillo Willies, which i realize is not aiming for the stars… At Orchard Supply House last weekend saw a Traeger or two, and was thinking placing a smaller version $499 range (although $439 on the Traeger website) next to my gas Weber Spirit.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Set & Forget - Pellet Smokers are the best solution for people who want to smoke meat for many hours without stress. The set & forget style is a domain of this type of grills. Just set the desired temperature and your smoker will maintain it for the following hours. That way you can leave your meat for even more than a dozen hours at a fixed low temperature without worries.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
On the better models, a temperature probe in the oven area tells the controller what the temperature is and if it is below the target it tells the controller to feed more pellets and air. The best manufacturers, like MAK and Memphis, have designed their own versatile custom controllers that are easy to use and can hold a temperature within 5°F, tighter than many indoor ovens.

Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.
What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.
Speaking of competition cooks, you’ll find that many competition BBQ pitmasters who use Pellet grills as their primary means of cooking are among the more well rested come Saturday. The next step we’ll cover in this selection of Pellet Grill Reviews is getting your pellet grill / smoker up and running. Again, what you may not see in may Pellet Grill Reviews is repeated mention that you’re not going to get that “deep smoke” flavor profile using a pellet smoker. Though, this can be achieved by using something like the Amazen Pellet Tube Smoker 12″.
So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!

In my experience, running Traeger pellets, the grill has functionally three temperature settings;  1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table.  2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs.  3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho.


Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Although our testers thought this grill was a bit heavy, they loved its small footprint and still found it to be very portable: “It’s a great size and convenient to bring in an RV or SUV for tailgating and grilling on the go,” reported one reviewer. Our testers were also pleased with how easily you could control the grill’s heat from its corresponding smartphone app. The only real downside? The instructions were a little unclear, according to one of our reviewers.
A few other mentionable features are that it has a highly durable temperature proof textures powder coat finish, it features auto start. The REC TEC Wood Pellet Grill accommodates temperatures from 180 degrees Fahrenheit to 500 degrees Fahrenheit with 5 degrees increment. This amazing temperature control features let you be in control of how much heat you want to cook your food in, without having to worry about it getting dry or burnt. This low increment allows you to cook delicate meats like fishes and seafood as well! It smart grill tech makes sure that the temperature you set is always consistent and constant. It also has an “Extreme” smoke feature from the 180 to 250 degrees Fahrenheit setting that intensifies the smoke in the grill.
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.

Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.
So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).
×