I purchased a Traeger Elite Grill from the website. I use the grill one time and it worked fine. A couple of weeks later we fired up the grill to cook some steaks. Approximately 10 minutes into cooking the auger stopped working. We had to finish our meal cooking it on the stove. I looked at the troubleshooting guide and the steps needed to be taken. To determine what was wrong you basically needed to dismantle the electric box and auger housing. I am not an electrician Nor a mechanic and feel this is excessive for a consumer to have to do.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
Thanks Kevin. I am about to buy both a 5 burner gas grill and a smoker for a new bbq island. Rather than buy both, will one of these higher end pellet grills take the place of a traditional propane grill? I can apply the funds for the gas grill to a higher end pellet if it can really do double duty. It has to be able to cook burgers and dogs and steaks etc. Just like a gas grill though. Thoughts?
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.
I had heard about Traeger from a friend who was at a conference where the catering was done on one of the commercial units. He had said the food the it made was mind blowing, and on a late night impulse buy I decided to purchase this from Amazon - as an open box/scratch and dent for about $800.There are some less expensive grills available, I have never owned them so I can't comment on them. i started to get a little buyers remorse with all the negative reviews this grill had received, but decided to give it a fair shot. It arrived quickly not by UPS but from trucking company. Despite being listed as damaged box/open box it was well packaged no damage. Assembly took 30 min by just me, assembly tools were included. Stood it up off the floor and filled the hopper with mesquite and followed break in procedure listed to cook off any manufacturing oil etc. Let it cool retired it once more to make sure it was seasoned let it cool again and was ready to go. I purchased an IGrill wireless thermometer to go with it which I would recommend also. I signed up to the Traeger recipe sight and they send a recipe every few days, and you can browse the website for some inspiration. Since I have owned this I have gone thru about 3 bags of pellets including alder mesquite and hickory. I have grilled Trout ( the smoked trout dip list on the website was amazing) as well as trout fillets, Salmon, Haddock, Ribs, Brisket, Pulled Pork x 3 and 2 prime ribs and 2 loafs of bread Jerkey ( smoking now) butternut squash etc etc . All the food I can only say is mind-blowing - enough so that 4 of my friends have purchased the smaller Traeger's for themselves. It has all been incredibly easy - just season, set the temp put the food on and the temp probes in and forget it- the wireless I grill continually upgrades my phone so I can keep working inside and not have to worry. It has never failed to light, caught on fire, overheated or preformed to anything other perfection for me. I can't speak for all the other negative reviews but I have had nothing but success with this, the Weber propane I own hasn't been touched is just taking up space it can't compare to this thing. Its a big purchase at close to 1k but is incredibly versatile I can't speak about customer service response because I haven't needed them, but if you are concerned I would call the headquarters and see how hard it is to get someone on the phone. The Temp probe is off by a few degrees compared to my Igrill reading but the grill has no trouble maintaining a narrow temp window if you keep the lid closed and don't F%$k with it . Most important it has bought back some passion to cooking, and made me want to try new things which is priceless.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.
Worst purchase of a product that I have ever made. After same issues the first and second cookings, I will use my good ole Brinkmann smoker from here on out. Shuts off with errors and after setting it on 250 will climb to over 400-450 degrees. They say you can set it and forget it, but I'm afraid that my home would burn down if I was not here watching over this junk. When you call customer service same old story. Take everything out, clean firepot put it all back together, then fire it back off. Take your screen out of pellet box and rake them. If you want to smoke meat you don't want to do this every 20 minutes or so. I gave over 600.00 dollars for this and have no more than 50.00 in my Brinkmann. Please read all problems with these before wasting your money!!!
Camp Chef have been a notable and solid producer of grills for some time now, and have earned their position in the market, with straightforward, yet proficient outlines, which offer purchasers great outcomes. They had stated, prior to release, that the PG24 Pellet Grill and Smoker, would give clients brilliant elements and a high level of usefulness, with exact temperature readings, and I needed to see whether this genuine. This Camp Chef PG24 Review expects to give purchasers all the data they have to settle on an educated purchasing choice.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.
Hey Boyd, it’s really great hearing from you here. I am becoming a much bigger Traeger fan then I was in the past. They have done some excellent work of late on their Grill models. I really think they’re doing a lot of work too improve and restate their original value proposition. Their Pro Series models are excellent, and I believe that the directions the company is taking especially with getting back into the competition world will benefit both it and its customers… Like you… Long into the future.
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet. 

The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.

With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.


When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.

Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.


These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.

The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
When you purchase this smoker, the cost is a bit more then some and less then others. Yet, I believe a great deal! One get's what they pay for. I believe this grill is a bargain at the price you pay. From the way it is shipped to me, I was throuoghly impressed with the attention to detail in packing and my receiving the smoker in perfect condition. It is a tank and the people I dealt with at All Things Barbeque, were first rate. If you have any questions, they would answer them. I plan on using the smoker in the next few days and can hardly wait. If the smoker works anything like the staff does at ATBBQ, it will be a grand slam! Kudos to everyone there and thank you for everything!
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.

Some products feature the wood-pellet fuel system as a bonus, but the Camp Chef SmokePro SG makes its wood-fired function the star of the show. Using 100% real hardwood pellets, recreating 5-star-cuisine level dishes on a large scale is now made convenient. Though it still has limited reviews, it wouldn’t be a surprise if this smoker quickly becomes a best-selling choice. It’s the kind of smoker that you need if you want hassle-free and fast cooking.
One final word of caution when it comes to pellet pricing.  If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it?  What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day?  We are all for saving money as much as anyone, but perspective is key here.  We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.
It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.

Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
×