Super excited to receive my brand new Traeger Timberline 1300 pellet smoker. When unboxing and putting together I noticed I was unable to attach legs due to damage to the unit. Instead of a nice round hole where legs would go, there was no holes, just where the hole should be smashed together. I instant contact Traeger and sent pictures of the damage requesting a new grill. They would not provide any case number and said they needed to review pictures which would take a few hours. 3 days goes but and no response. I open a PayPal dispute (NOT claim) and they contacted Traeger again. Now they refuse to do Anything unless I close the dispute but if I close dispute, I lose all my consumer protection. They could of handled this situation so much better. I will never purchase a smoker from them again. Horrible customer care.

There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.

The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!


As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)
This review is just a repeat of many already submitted.  Got my Traeger Elite 34 this summer at a trade show.  It would not get up to temperature, wouldn't go about 360deg with food inside.  Empty it would hit 390 max.  Most of the 'infamous' Traeger recipes call for 400+.  If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover.  I called Traeger and they claimed their grills 'never do this'.  After reading dozens of reviews since, the truth is that they seem to 'usually do this'.  The big grilles just do not have enough BTUs to heat up properly.
Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
I bought the Pit Boss 440 Deluxe & cooked a pork butt. Set it on Smoke (P4) all was well for 2 hours then temperature ran away to over 615 degrees. Ruined that piece of meat. Called customer service & they talked at me instead of listening to me. Tried another pork butt set on 225 degrees temp once again ran away after an hour. Wrote an email to customer service with a response that they were sorry I was having trouble. Tried again today with the same result so sent another email with pictures of settings & indicated temperatures. Guess I'll have to finish this pork butt in the oven & go buy a Treagar Pellet Grill. If Pit Boss corrects this I'll update this review!
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
Bought my Texas Elite 34 Traeger pellet grill last summer at Oshkosh Fly-in. Received it and assembled it with no issues. Began using it and discovered it will not make temperatures above 375 deg F. Most of the Traeger recipes need 400+ deg, so this wouldn't work. Called Traeger. They started sending me replacement parts, first the combustion air fan, then the auger motor, then a digital temp controller. None of these new parts had any effect on the problem. I have probably called Traeger 10 times, finally getting a hold of a second level supervisor named Jessie. He decided to send me a whole burner module; pellet hopper, auger tube, burner bowl, fan, controller... everything in one assembly. I installed it and no improvement. I did a time vs temp test for them at their request. They finally agreed it wasn't working properly.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
Camp Chef SPG-90B 30,000-BTU 3-Burner Big Gas Grill:3 burners30,000-BTU burnersAppliance-style control knobsIndependent leveling l...egsCamp Chef gas grill has a removable grilling attachmentConvenient carrying handles on the barbecueGas grill hose and regulatorSide shelf and a hinged-lid barbecue box that covers 2 burnersCast-iron, pre-seasoned grate to sear in flavorMassive grilling surface30,000-BTU gas grill is a versatile outdoor kitchenAllows you to barbecue and grill meats quicklyBurners produce three times the heat of a normal kitchen stoveUse for tailgating and other outdoor eventsAllows you to switch out cooking accessories to meet your needs16" surfaceUse the 3 stove burners in any pot, pan or skillet configuration read more
We have already mentioned this product in our review once and we’re talking about it again. Whenever you are thinking of Green Mountain Grills, Daniel Boone should always be your first choice; it’s simply the best among the GMG products we reviewed. Due to having other products at much lower prices with the same features, we could not include Daniel Boone in this review. We have, however, included the Davy Crockett in our review as our Budget Pick.
Camp Chef SPG-90B 30,000-BTU 3-Burner Big Gas Grill:3 burners30,000-BTU burnersAppliance-style control knobsIndependent leveling l...egsCamp Chef gas grill has a removable grilling attachmentConvenient carrying handles on the barbecueGas grill hose and regulatorSide shelf and a hinged-lid barbecue box that covers 2 burnersCast-iron, pre-seasoned grate to sear in flavorMassive grilling surface30,000-BTU gas grill is a versatile outdoor kitchenAllows you to barbecue and grill meats quicklyBurners produce three times the heat of a normal kitchen stoveUse for tailgating and other outdoor eventsAllows you to switch out cooking accessories to meet your needs16" surfaceUse the 3 stove burners in any pot, pan or skillet configuration read more
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.

Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.
All of GMG’s like of product lines like the Daniel Boone and Jim Bowie come with similar features. In fact, the Daniel Boone will always be a better alternative to the Davy Crockett. However, the Daniel Boone line isn’t winning any spot in our budget pick due to its higher price tag. With its build and quality, it does become one of our honorable mentions, if not the pick; and the Davy Crockett continues to be the top choice for the grillers on budget.

†Advertiser Disclosure: Many of the card offers that appear on this site are from companies from which CreditDonkey receives compensation. This compensation may impact how and where products appear on this site (including, for example, the order in which they appear). CreditDonkey does not include all companies or all offers that may be available in the marketplace.
Now we come to the part no one likes and that’s cleaning. This smoker won’t clean itself but it does make the process a lot easier. PG24 by Camp Chef Pellet Grill is created in a way that gives you easier access to the fire pot making cleaning out the ash effortless. It also has trap door that allows you to clean the unit without scouring through grease and ash. Anyone who has ever had to clean a smoker grill knows how time-consuming and enormous the task can be. This trap door is only present in expensive units, but you’ll be glad you paid a little more when cleaning becomes effortless. You could also buy the other version that could come with cover (which is $50 more expensive) to make sure the smoker is in the best condition at all times.
Wood pellet grills look like standard barbecue grills but some with a separate firebox for making smoked meats that will also let you smoke vegetables and other ingredients. As Traeger and Pit Boss both get good reviews from customers, it’s important that you look at the top features of this grills and how each company compares in relation to those features.

First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!
The best pellet grill smoker has the benefit of being easy to light and easy to use. With a pellet smoker, you put the pellets in the hopper, light the heating unit, and you don’t have to worry about it. Conversely, with a charcoal smoker, you have the struggle to light the charcoal, and then throughout the entire cooking time, you need to check the backup on the unit to make sure that it’s functioning properly.

What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.


The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
With 341 square inches of cooking space and a digital control board that sets the temperature from 180 to 500 degrees, you’ll be cooking whole meals in this grill, even though it’s the smallest model that Pit Boss makes. It will hold up to a dozen burgers for parties, or a chicken and vegetables for the family dinner. When cooking is done, the porcelain coated grill grates are easy to clean.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.

To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
Provide year-round protection for your grill with this Provide year-round protection for your grill with this Dyna-Glo Premium BBQ Cover. Made with water resistant heavy duty PVC shell and 900 Denier polyester lining to withstand harsh elements. Double-stitched seams provide additional strength and durability to help prolong the life of the cover. This cover also features durable nylon ...  More + Product Details Close
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.

With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
Maintenance is an issue. There are moving parts on these grills. Moving parts eventually break. There is an auger with a motor, and a fan with a motor. There are proprietary electronics systems on these babies. Augers clog. Motors burn out. Electronics have bugs or fail. Especially when exposed to rain, snow, hot, and cold. When they fail, will the manufacturer have a replacement part?
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Just what I needed for my Traeger Pro 22. Fits like a glove, simple install, and makes adding and pulling rib racks off the smoker much easier. No longer a balancing act trying to get a tray to stay put on top of the pellet hopper lid. This also fits perfectly under Traeger's cover for the Pro 22 models. Have to be a little care you dont pinch your fingers when folding it down (would be a nice future mod if it could somehow be spring assisted), but thats my only gripe.
The Camp Chef Collapsible Garbage Can is a handy container for removing leaves, cleaning up after parties or for use on camping tr...ips. This camping garbage can contains spring-loaded setup for fast and easy use. Two plastic toggles keep it collapsed for transportation and storage. Made from Polyethylene construction with metal coil support, this collapsible garbage can is rugged. The 35 Gallon Garbage Can provides for cleaning up a large area without having to stop to dump in between. Featuring dual carry handles and a built-in zippered lid, this garbage can is convenient for tailgating, backyard barbecues and more. read more
The wood pellet grill features a dual rack design with a 513 square inch main cooking surface and 187 square inch warming rack. With a 20-pound hopper capacity, the grill has plenty of space for wood pellets to keep grilling during long event and parties when you have many mouths to feed. An automatic pellet feeder makes it easy to maintain the desired temperature, so you can focus on just the grilling itself.  
At the end of the day, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet smokers use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.

Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:


Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
For me, grilling is a way to communicate to the people in my life that I love them and to easily involve others in my passions and hobbies. So, to be able to guarantee perfection in every meal isn’t just about eating well, it’s about reliably being able to put my best foot forward with these people who matter. And the remarkable thing about the Traeger is that you can expect to be able to do the same from the very first time you use it.
Most grills feature a primary cooking area (the main grate) and a secondary cooking area (additional racks). In a pellet grill, there’s less difference between the two grilling areas because it mainly cooks by indirect heat, so the temperature is the same throughout the grill. It’s best to pay attention to a pellet grill’s total cooking area because it is the sum of the primary and secondary cooking areas.
But as said, there are a few things we don’t like; it’s relatively small, doesn’t have a lot cooking space, and the design feels cramped. At the same time, it’s still relatively heavy at 140 lbs. For the same price, you could choose the Z-Grills Master 700D, which packs almost 25% more surface area on the rack. That doesn’t seem like much but is a significant amount of room.  Or you could just spring for the Traeger Pro 22. There have also been reports of poor quality control, and that the temperature control is very inconsistent, often swinging up and down nearly 30 or 40 degrees.
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!
In 1982 Traeger Heating in Oregon began experimenting with a furnace that would burn wood pellets made from compressed sawdust, a byproduct of the area lumber mills, and before long introduced a home heating system that they sold mostly locally. Since furnaces sold mostly in cold months, before long they began experimenting with a grill that would burn pellets, too. Eventually they created a device with an auger to feed the pellets and a blower to help them burn.

Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.

When it comes to spending your own hard-earned money on a new wood pellet grill, you want to invest in a product that is going to last you for a while. There are many differences between purchasing a cheap wood pellet grill and a pellet grill that is built with quality materials. Even though the cheaper grill may be easier on your wallet in the short run, the long-term costs will quickly outweigh the initial savings. So, if you’re thinking of buying a cheap pellet grill, continue reading to learn about the true costs that could be associated with your decision.

Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.


This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.
Hey Jeff – I think that due to pellet smokers requiring much of the wood pellet for “fuel” leaving a smaller part for the “smoke” means that you want as much of the smoke to stay in the chamber for as long as possible. Just my opinion. I’ve not used charcoal pellets. Those I’ve spoken with who have used them weren’t extremely happy with the results. Regarding the water pan, I feel that pellet smokers don’t typically require water pans. However, you can surely use one and see how your results go.

If the metal is too thick, you will also use a lot of pellets. The walls of a thick-bodied smoker act as a “heat sink”. Heat is taken away from the cooking area and stored in the walls of the cooker. So, it will take a lot of pellets to get the cooking area up to the desired temperature. While thick walls are desirable for some types of cookers, they are not required in pellet smokers.
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.
Yoder smokers are named after the size of the cooking surface. The YS640 pellet smoker has 640 square inches of grilling surface. In addition, you can get yourself a removable second shelf that adds 65% to the cooking surface area – bringing the total space to 1,070 square inches. The entire smoker is built out of quality materials and come with a lifetime guarantee against burnout.

Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Z Grills is a lesser known manufacturer and a great low-cost alternative to the more expensive Traeger grills. Their pellet grill is a sturdy, heavyweight model with a roomy 500 square inches of cooking space and an electronic feeding system for fuel pellets. An additional warming rack provides additional space for cooking at lower temperatures. Furthermore, Z Grills also ensures their product with a generous 3 years warranty.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
×