The best pellet grill smoker has the benefit of being easy to light and easy to use. With a pellet smoker, you put the pellets in the hopper, light the heating unit, and you don’t have to worry about it. Conversely, with a charcoal smoker, you have the struggle to light the charcoal, and then throughout the entire cooking time, you need to check the backup on the unit to make sure that it’s functioning properly.
The single burner Camp Chef Barbecue Box Accessory turns your outdoor gas stove into a portable barbecue grill. This grill system ...will greatly enhance your outdoor cooking experience with a wider variety of meal choices. With the patented diffuser plate you don't have to worry about hot spots. The diffuser captures and vaporizes the grease, infusing your food with a rich BBQ flavor. The cast iron cooking surface holds the heat and sears the meat. A vented lid is included to help keep the heat in. This system covers one burner on the Camp Chef Professional, Sportsman, Outdoorsman, Explorer, and OSD Models. It does not fit the Sport Utility Stove. read more
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.

When it comes to buying a new pellet grill, do yourself a favor and conduct some serious research on the grills you are looking to purchase before jumping into it. Just because a pellet grill looks sharp on the outside and has a cheap price tag to go along with it, doesn’t necessarily mean you’ll have spent less money over the course of three or four years compared to buying a well-built pellet grill with a good warranty.
Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..

Kevin, your recommendation rocked. The Pro is one of the best pieces of grilling and smoking iron I have had my hands on in a long time! Better than the Backwoods? Well depends on how much work you want to do! Maybe not, they are first class, but ease of use? I use the Backwoods a couple times a year, the Pro has already done 8 cooks in 5 weeks. Love it.
When you purchase this smoker, the cost is a bit more then some and less then others. Yet, I believe a great deal! One get's what they pay for. I believe this grill is a bargain at the price you pay. From the way it is shipped to me, I was throuoghly impressed with the attention to detail in packing and my receiving the smoker in perfect condition. It is a tank and the people I dealt with at All Things Barbeque, were first rate. If you have any questions, they would answer them. I plan on using the smoker in the next few days and can hardly wait. If the smoker works anything like the staff does at ATBBQ, it will be a grand slam! Kudos to everyone there and thank you for everything!
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!

The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.


“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
After 10 days of not seeing anything in my email I called them. They told me they had no order. After two weeks and more phone calls then a grill finally shows up but without the cover or the pallets which I paid for and was on the order. Three calls into managers and customer service still not resolved. When I threaten to take the grill back to Costco I was told to go ahead and have a nice day.

Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!


Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.

The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.


Are you sick and tired of bad BBQ? Well, so are your friends, neighbors, and family members. With the Woodwind woodfire pellet grill, mediocre grilling can be a thing of the past. Put the bland chicken and burnt steak behind you, and become the grill master you were born to be. With digital temperature control, the Woodwind does all the work for you. All you have to do is turn it on, set the temperature, and let it work while you play. Which means no more babysitting! The Woodwind doesn’t just make grilling easier—it also makes it more delicious. The Woodwind is fueled by premium hardwood pellets to generate heat and smoke, infusing your food with a savory wood fire taste that’ll make your taste buds sing. With grill temperature settings from 160° F to 500° F and the included Sear Box that reaches up to 900° F, you can achieve perfect results, whether you’re grilling, smoking, baking, roasting, braising, barbecuing, or even searing. And when you’re finished cooking, cleanup is a breeze with our patented Ash Cleanout system. Discover the heavenly taste of a woodfire pellet grill with the Woodwind. Buy now to begin your journey to grill mastery.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
I bought the Pit Boss 440 Deluxe & cooked a pork butt. Set it on Smoke (P4) all was well for 2 hours then temperature ran away to over 615 degrees. Ruined that piece of meat. Called customer service & they talked at me instead of listening to me. Tried another pork butt set on 225 degrees temp once again ran away after an hour. Wrote an email to customer service with a response that they were sorry I was having trouble. Tried again today with the same result so sent another email with pictures of settings & indicated temperatures. Guess I'll have to finish this pork butt in the oven & go buy a Treagar Pellet Grill. If Pit Boss corrects this I'll update this review!
The fight for building the cheapest pellet smoker with decent quality is pretty intense. Unfortunately, a cheaper pellet grill often leads to lower quality construction. The Camp Chef SmokePro DLX is more expensive then the Pitboss 71700fb, and in our opinion the Pitboss is the better pellet smoker. It isn’t a bad unit; the controller of this smoker even includes a meat probe which typically comes only with the more expensive units. However, it does have one flaw – the lid.
Its advanced cooking system comes with a “set and forget” temperature control system that is monitored using its programmable meat probe. Its flame broiler allows for direct and indirect cooking. It has an automatic start up and cool down feature and LG’s proprietary exhaust mechanism for even second tier cooking. Its adjustable temperature can be set from as low as 170 F to 600 F.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control. 

The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.

3.) Had everything set up to bake pizza's . Started up the grill. Installed pizza oven in grill. After about 1 hour grill only got to 280 degrees. Desided we needed to eat dinner and 2 pizza already mad up I placed the pizza's in the grill. 3 minutes later yhe temperature started to go down. Finaly after grill was at 80 degrees I received a message that there was no fire. I removed the pizza oven with pizza's still in. The fire box was full of pellets not burned. I reset the grill and started it back up and no fire message again. Grill is broke again . Only had this grill for 5 months, usef it 6 times and 3 of the times it ruined my cookout.
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase
I have been cooking Southern BBQ for 40 years, my Dad did the same. I have bought ever kind of grill on the market, built many of my own because none of the store bought grills cook very well and don't last because of cheap construction. Had been researching Pellet grills for some time and decided on the YS640. Received the grill yesterday and very impressed on everything from boxing to construction of the grill. Just fired it up to burn it in. Temp stays @350. This grill is well made, USA made ! Which is important to me. Cant wait to cook on it, know it will do the job. Thanks..All Things BBQ.....
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
The ceramic stone promotes even heat distribution and the domed ceiling design mimics the same heating pattern as a wood fired bri...ck oven. Preheats in just 15 minutes, exceeding 600°F if needed. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.

I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
But if you like the idea of a wood pellet grill, one of the oldest names in wood pellet grilling is Traeger, which developed some of the first units to use this technique three decades ago. Having that name recognition gives Traeger a leg up versus some of its competitors. And for the most part, Traeger’s grills live up to what consumers expect from this established brand, providing good design and longevity. They don’t typically match up with the higher end models currently on the market in terms of precise cooking temperatures, but Traeger is a nice mid-range product with several price points available.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
We have already mentioned this product in our review once and we’re talking about it again. Whenever you are thinking of Green Mountain Grills, Daniel Boone should always be your first choice; it’s simply the best among the GMG products we reviewed. Due to having other products at much lower prices with the same features, we could not include Daniel Boone in this review. We have, however, included the Davy Crockett in our review as our Budget Pick.

Generally speaking cheap grills are not made with quality materials. While the outside may look good, often times you will find the guts of the grill are made with lower grade metals. This of course affects functionality and longevity. If the inside of the grill isn’t made using quality materials you will literally burn through it over a certain period time.
Second, more people know about them. More manufacturers are realising the advantages of pellet smokers and hopping on board, the market is expanding, and with the advantage of the internet putting all the info at our fingertips, even someone who hasn’t got the first clue about smokers and grills can find out everything they need in just a few minutes.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
What’s more, it has an LED display with a Digital Elite Controller for temperature control. Judging by its ratings, unlike the other grills on this list, its temperature and quality controls work just fine. This grill also has an electronic auto-start ignition and easy-to-clean grill gates to boot. Its quality control isn’t perfect though, and some faulty units slipped through the cracks.
I have owned this pit for over a year and a half now. I previously had a stick smoker which I achieved really good results with but it was time-consuming. But this baby takes it up to a whole new level.everything comes out amazing competition quality. My Family and friends are amazed by these results , The ribs and pulled pork are the best I have ever eaten. My brisket used to always come out average not on this machine.It's extremely juicy and mouthwatering. I would definitely recommend the top shelf and two side probe ports. The heavy duty cover is also top notch I have extremely Highwinds where I live here and the cover works perfect.everything that I have smoked has come out amazing. The juiciest turkey and chicken and even ham first class.I use mine all year even when it's 0° outside just amazed. Pull the trigger and buy this baby you'll never look back. Thank you Yoder for making a great product.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.
×