This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
I have found that using the upper shelf gets more airflow around the meat than the lower shelf. I asked the AmazingRibs.com science advisor Prof. Greg Blonder about the problem (he has a MAK 1 Star). He explained that smoke sticks to cool surfaces and wet surfaces, and the surface of meat warms and dries out after a few hours. When he wants more smoke flavor he uses a strong smoke wood like hickory or mesquite, he starts with cold meat, and then he keeps the meat moist by painting or misting it with apple juice or a mop like Lexington Dip or East Carolina Mop or Texas Mop Sauce. A awter pan can help because the water condenses on the cool meat and attracts smoke. Read his detailed research on the subject in my article on the Science of Wood and my article on Basting.

The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.

There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.

The Redwood Portable Fire Pit is an upgrade from the original Gas Fire Ring. A taller, more sturdy base stand, safety ring/carry h...andle, matchless ignition, and a laundry list of other features, the Redwood is the next step in portable propane fire pits. Camp Chef Gas Fire Pits are allowed for use in most fire ban restrictions, check with the local Ranger Station before use. read more

The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.

The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually.
3-DFT12 Size: 12" Features: -You can now take the guesswork out of outdoor grilling and concentrate more on the beauty of the grea...t outdoors. -Allow yourself to effortlessly monitor and regulate the temperature of your grill with the Camp Chef Thermometer. Product Type: -Thermometer. Finish: -Silver. Tool Head Material: -Other. Number of Items Included: -1. Dimensions: Overall Product Weight: -1 Pounds. Size 6" - Overall Height - Top to Bottom: -6 Inches. Size 6" - Overall Width - Side to Side: -2 Inches. Size 6" - Overall Depth - Front to Back: -2 Inches. Size 12" - Overall Height - Top to Bottom: -12 Inches. Size 12" - Overall Width - Side to Side: -2 Inches. Size 12" - Overall Depth - Front to Back: -2 Inches.Package Quantity : 1 read more
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 — using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.

Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?


If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.
With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.

They are often called grills, but, at the time of this writing, I consider them to be primarily smokers. Almost all of them cook with indirect heat and those that try to grill over direct flame don't do it well. If you love steaks, there are far better ways to cook them. But if you love smoked turkey, ribs, salmon, pork chops, brisket, and smoked foods, a pellet smoker may be the best solution available.


With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.
The greatest thing about pellet smokers is that you don’t have to do much to get perfectly smoked dishes. Simply set the digital controller to the desired temperature and the smoker will do the rest. These smokers are pretty much set-and-forget, which means that you’ll be able to spend more time with your guests and still serve them food that has wonderful smoked flavor. It’s this convenience that’s led to the recent rise in pellet grills and other electric smokers.

After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.

I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.


A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.

On the better models, a temperature probe in the oven area tells the controller what the temperature is and if it is below the target it tells the controller to feed more pellets and air. The best manufacturers, like MAK and Memphis, have designed their own versatile custom controllers that are easy to use and can hold a temperature within 5°F, tighter than many indoor ovens.
A: As one of the most frequently asked questions, consumers want to know if the grill comes with a grill cover to protect the grill. With that said, most brands do have a grill cover when it comes to the grill. However, it is important to always as the manufacturer if they include a grill cover with the purchase. In most cases, the grill cover is made from some of the best materials in the industry for durability and functionality.
Camp Chef Stryker 4-Piece Cook Set, Silver:Heat Ring technology increases efficiency by 30 percent, reducing fuel consumptionWorks... with any Mountain Series stoveFolding handles for easy packingLightweight, hard anodized aluminumTwo-Liter pot with lid7.5" frying panFour-piece cookware set includes mesh carry bagA pot support adapter, sold separately, is necessary if using a Stryker stoveThese products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.
You can whip up a delicious meal in no time with the Camp Chef Dutch Oven Stand. This cooking stand is especially convenient for t...hose who want to do tabletop cooking, as the stand gets your oven to just the right level so that you can make your food with ease. The heavy-duty steel platform of this Dutch stand ensures durability. This stand is designed to hold a 14 inch Dutch oven and should be placed only on a non-combustible surface. read more
A portable offering from Green Mountain Grills, the Davy Crocket is the most affordable pellet grill on our list, and the only one with WiFi capability. It’s compact, weighs only 57 pounds, and has folding legs so you can pack it up and bring it camping, tailgating, or to the beach. That’s something you can’t do with the Traeger Pro 22, and something we’re really excited about.

I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.  

As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
A good pellet grill can hit high temperatures for that perfect steak and still hold a steady low and slow temperature for great barbecue. All the while adding great smoke flavor from hardwood pellets. These pellet grills cost more but do so much more while being highly efficient, precise in temperature and widely capable. Among these, you will find cookers large enough for a whole hog as well as units with full network interfaces for controlling from a distance. These are the best of the best in Pellet Grills.
Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
It is almost as we have forgotten how to live life the way it should be lived. We no longer have the time to sit back on a summer’s day, and appreciate the show that nature has put up for us. Now-a-days we are so committed to our work, responsibilities and duties towards the external that we often forget that we have our very first priority neglected: happiness. We are so engaged in our daily 9 to 5 routines that we have actually began to take it as a way of living while it slowly drains and strains us away over time. 
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.

This smoker offers a decent 418 square inches of grilling space. This is enough to cook around sixteen burgers or four whole chickens. If the grilling space isn’t enough, Traeger also offers a larger unit that offers the same features at a higher price range. But the medium sized one is enough to cook for large groups of people already. Built to have a high capacity, this smoker allows for multiple cooking at the same time.

Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
Still loving it after cooking about 100 meals. Thru rain, snow, and the occasional nice day it is still going. Today I'm about to grill brats. My weber grill sits around rarely needed so it's going to get sold. I discovered with quality pellets it can grill just fine to temps up to 450. The camp chef grill cover keeps the pellets dry in the hopper so I don't even take them out unless you want to change flavors. I did have to seal the hopper handle around the rivets to keep the rain out but other than that it is very tight. See the pic makes smoke like crazy.
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.

This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.


Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.

When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.

One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.


With the internal temperature sensor, meat temperature probe, and a digital temperature readout, the PG24 pellet smoker takes the guesswork out of your cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The patented Ash Can Cleanout System makes clean up the easiest out there.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.

I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.

But as said, there are a few things we don’t like; it’s relatively small, doesn’t have a lot cooking space, and the design feels cramped. At the same time, it’s still relatively heavy at 140 lbs. For the same price, you could choose the Z-Grills Master 700D, which packs almost 25% more surface area on the rack. That doesn’t seem like much but is a significant amount of room.  Or you could just spring for the Traeger Pro 22. There have also been reports of poor quality control, and that the temperature control is very inconsistent, often swinging up and down nearly 30 or 40 degrees.
But if you like the idea of a wood pellet grill, one of the oldest names in wood pellet grilling is Traeger, which developed some of the first units to use this technique three decades ago. Having that name recognition gives Traeger a leg up versus some of its competitors. And for the most part, Traeger’s grills live up to what consumers expect from this established brand, providing good design and longevity. They don’t typically match up with the higher end models currently on the market in terms of precise cooking temperatures, but Traeger is a nice mid-range product with several price points available.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.

Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.

Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.

After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.


My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!

What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.
×