Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.

Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..


Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.
114 deals were found for Pit Boss Pellet Grill. Deals are available from 7 stores and 4 brands. An additional discount is available for 24 items. Last updated on December 20, 2018. Scanning all available deals for Pit Boss Pellet Grill shows that the average price across all deals is $332.75. The lowest price is $1.99 from amazon while the highest price is $1,299.99 from Kotula's. The average discount we found across all deals is 18.92%, the largest discount is 49.54% for the product Pit Boss 700FB Classic Pellet Grill Cover from Walmart.com. New products prices vary between $1.99 and $1,299.99. Free shipping is offered across 6 stores - amazon, ebay, Hayneedle, Kotula's, Walmart.com, Wayfair.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Yoder smokers are named after the size of the cooking surface. The YS640 pellet smoker has 640 square inches of grilling surface. In addition, you can get yourself a removable second shelf that adds 65% to the cooking surface area – bringing the total space to 1,070 square inches. The entire smoker is built out of quality materials and come with a lifetime guarantee against burnout.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.

Rec Tec Wood Pellet Grill boasts a cooking area of over 1000 sq. inches. However, that area is calculated from its optional cooking shelf. Without it, the cooking area is roughly around 700 sq. feet. This removable shelf can allow you to increase your cooking area if you’re trying to cook patties, steaks, chicken pieces and items as such; or they can be removed for granting a greater volume of space for smoking brisket or whole turkeys.
The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
Right off the bat I could tell this smoker was made in America! While putting it together the holes actually matched up! ATBBQ- beat the 5-6 week lead time and delivered in two weeks out to California. This thing is a beast- the heavy weight I was looking for in a smoker and it has the most consistent temp I have ever had with a pellet grill. I messed up on the first pellet grill that starts with a "T" and should have started out with the Yoder YS640. If you are on the fence or wondering if it's truly worth the cash. All I can say is yes...YES it is. Pull the trigger and order this now- you won't be disappointed. I don't work for Yoder or ATBBQ- I'm just a experienced BBQ'r that could not be happier! Thanks Yoder and ATBBQ,
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.

We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:


Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.


This Bayou Classic outdoor patio stove offers a This Bayou Classic outdoor patio stove offers a wide range of cooking options operating from a bare simmer to a full blast flame. This outdoor grilling alternative is portable enough to take around with you camping tailgating hanging out in the backyard and road tripping in your RV. Despite its ...  More + Product Details Close
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.

Rec Tec Wood Pellet Grill boasts a cooking area of over 1000 sq. inches. However, that area is calculated from its optional cooking shelf. Without it, the cooking area is roughly around 700 sq. feet. This removable shelf can allow you to increase your cooking area if you’re trying to cook patties, steaks, chicken pieces and items as such; or they can be removed for granting a greater volume of space for smoking brisket or whole turkeys.

×