Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.


The ceramic stone promotes even heat distribution and the domed ceiling design mimics the same heating pattern as a wood fired bri...ck oven. Preheats in just 15 minutes, exceeding 600°F if needed. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
Hey Kim – thank you for this. I’ve had this happen with numerous pellet smokers, including GMGs. What happens most often when it happens is that I’ve been remiss in properly cleaning the grill out after several uses (vacuuming the fire pot out). This causes the ash etc to cover up the heating rod, thus making the temperature lower than expected. The auger keeps feeding the fire pot to compensate and you get what you’ve described.
Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
You want to easily switch to different smoky flavors: Changing flavors in your Traeger grill is as easy as changing the pellets that you place in the hopper. Through its website, Traeger offers several different smoky flavors of hardwood pellet offerings, including hickory, mesquite, apple, maple, cherry, and oak. And Traeger’s website provides information on which types of hardwoods provide the best smoky flavor for certain types of foods, which can help you successfully use this grill immediately out of the box.

Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.

Good info, but it’s missing something… the cost to use. I’ve been looking for a long time to get into smoking. I have only ever used a propane setup for grilling. My main quesion is the cost to use propane vs charcoal vs pellets. I’m very interested in pellet smoking AND grilling. A couple times a week my wife and I will grill some chicken breasts or steaks. Can you breakout an approximate cost comparison to run the different methods? Appreciate it!
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.

Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazonhttps://tinyurl.com/amazingribs
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
With that being said, it’s necessary to understand how much wood pellet would last you and for how long. A 40-pound bag of wood pellets would last you for approximately 24 hours if burned at 250 F. Therefore, if you’re trying to slow-cook a large piece of brisket for 14 hours straight, your 6-9 lb hopper capacity just won’t cut it. You’re going to have to refill it in the middle if you wanted to continue cooking.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.
Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

The big structure makes it great for searing large amounts of meat at the same time. When it comes to high temperatures, you need to know that it only reaches 450~ degrees F. It’s not a lot, but you have to know that the main characteristic of this grill is maintaining low temperatures for a long time which allows for reliable, easy and slow meat searing.
This smoker is one totally awesome product. It is more that just a smoker, it is a true convection oven, we have baked bread in it! As for being able to hold the temp for low and slow, wonderful. The beef that I smoked was delectable. I just this week smoked 10 venison loins at the same time; it took 1 hour for the most tender, delicious venison I have ever tasted!
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.

Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.


I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.
Most pellet smokers are wood-burning ovens: great for ribs, turkey, brisket, and pork shoulders, but not so great for grilling steaks and burgers. The FEC PG series was one of the first lines of pellet burners to offer a sear station, a cast iron cooking grate right over the fire pot where the wood pellets burn. It isn't the best setup for searing, but it's better than most other pellet searing schemes. The real beauty of the Fast Eddy's design is that it produces meat with a deep mahogany finish, much like a competition-grade offset smoker. It also has two upper-level heat zones, for a total of four distinct temperature zones.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
Just started shopping around for a pellet smoker. Am also going to need a new gas grill soon. Stopped in at the local BBQ supply store today and they showed me the Memphis Pro and said it would function well for both smoking and cooking steaks/burgers. Price point on that one is pretty high. Would any of the others reviewed above offer similar functionality? Do you have a recommendation of which will work well for both functions? I live in KS so kind of like the idea of sticking with the local guys from Yoder, but Fast Eddys in OK isn’t too far away either. Thanks.
Louisiana Grills is a respected brand when it comes to pellet smokers. It was one of Traeger’s earliest competitors that entered the market after the original Traeger patent expired. The biggest difference between the two brands is that Louisiana Grills makes pellet smokers with advanced features for a relatively affordable price. The Louisiana Grills LG700 is no exception. It has a one-touch PID controller, a programmable meat probe, an adjustable flame broiler for direct grilling, an upper cooking rack and a lower storage shelf.
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase

First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
But, along with some shelves we don’t need, a headboard that won’t fit our new bed, and a gigantic chest freezer I haven’t yet filled, the Egg has languished in the back corner of the garage since then. That’s because a brand new Traeger Timberline 850 was sitting here waiting for us when we arrived and it’s performed so well and become such an essential part of my cooking that now I can’t imagine using anything else. 
×