The fight for building the cheapest pellet smoker with decent quality is pretty intense. Unfortunately, a cheaper pellet grill often leads to lower quality construction. The Camp Chef SmokePro DLX is more expensive then the Pitboss 71700fb, and in our opinion the Pitboss is the better pellet smoker. It isn’t a bad unit; the controller of this smoker even includes a meat probe which typically comes only with the more expensive units. However, it does have one flaw – the lid.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.

Third, we’re experienced: We have burnt our foods and fingers; and while we were at it, we learned from our mistakes. In doing so, we’ve managed to become the best and mastered the art to perfection. So, we went through the same learning curves that you did or might do. So, we’re aware of the things that matter and we’re going to impart that knowledge with you, so that you don’t make the same mistakes as us.


Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
Rifles Delivery Confirmation-Adult Signature Required. Customer must provide a physical address for delivery of this item. Cannot ship to a PO Box or APO/FPO addresses. Black powder rifles are not shipped to customers in IL, MI, NJ, NY and Washington, DC because of restrictions. This item will be removed from your order if your shipping address is to a restricted location.

I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!
There is a bit of a learning curve when cooking with pellet grills. This unit can smoke, grill or bake similar to an oven. The Traeger smokes at 180*, but can cook up to 450*. It is indirect heat, so you can grill a ribeye without flare ups. My unit holds temps within 5+/- of the setting. Yes, you do have to clean it like a fireplace, it doesn't run on gas. The build quality is amazing, especially for a PRC manufacture. If you are interested in a pellet grill, buy a pellet cookbook. Something that gives smoke and cook times for an easier introduction into pellet cooking. The only knock against the unit is that for $800 it should have came with the "optional" folding shelf...

To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.

The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.


Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
WOW, that’s all I got. What an amazing piece of cooking equipment. I’ve owned mine now for a little over a year, and to be honest, each time I use it, I learn something new about it. I’ve cooked on Traeger’s and owned several Bradley smokers. But nothing compares to the versatility of the Yoder. This thing is well made (its heavy) and it cooks flawlessly. The worst thing about it is the need to empty the ashes, and it’s not that big of a deal. I will say, invest the money and buy the heat diffuser with the access door. It makes removing the ashes so much easier. Ask yourself this question, how many different flavors of propane can you use on your grill. Because with all of the different wood options for this, it’s almost limitless. Make the investment, you won’t be sorry
While there's not a lot to dislike about pellet smokers, it really comes down to your cooking/grilling style.  Some Smoking Geeks prefer pellet smokers to traditional smokers (or even the Green Egg style smokers) testifying that flavor is superior to that of other styles of smokers within the price range – and it's hard to argue with them.   While Traeger is the pioneer, there are other brands that give it a run for its money.
After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.
Due to having such features and being the best Lousiana Grills Product, the Louisiana Grills LG Pellet Grill 1100 could not escape our vigilant gaze when we did our research. However, it had some shortcomings, mainly due to its build and price that did not allow it to make it into our pellet smoker review. Regardless, we could compare it with some of our products that it had tied with. But as always, we could only choose the top 10 products for this review and this had to go. Regardless, this still is a great product, worth mentioning.
I have found that using the upper shelf gets more airflow around the meat than the lower shelf. I asked the AmazingRibs.com science advisor Prof. Greg Blonder about the problem (he has a MAK 1 Star). He explained that smoke sticks to cool surfaces and wet surfaces, and the surface of meat warms and dries out after a few hours. When he wants more smoke flavor he uses a strong smoke wood like hickory or mesquite, he starts with cold meat, and then he keeps the meat moist by painting or misting it with apple juice or a mop like Lexington Dip or East Carolina Mop or Texas Mop Sauce. A awter pan can help because the water condenses on the cool meat and attracts smoke. Read his detailed research on the subject in my article on the Science of Wood and my article on Basting.
Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.

It is great when it comes to smoking meat at low temperatures, regular grilling, baking or roasting. You can have problems, though, if you want to sear your meat, it requires much higher temperatures. Sadly, a regular pellet smoker cannot reach them. In that case look around for a pellet grill that comes with an additional sear box that is gas fueled and can heat up to 900 degrees F.
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.

I bought the Pit Boss 440 Deluxe & cooked a pork butt. Set it on Smoke (P4) all was well for 2 hours then temperature ran away to over 615 degrees. Ruined that piece of meat. Called customer service & they talked at me instead of listening to me. Tried another pork butt set on 225 degrees temp once again ran away after an hour. Wrote an email to customer service with a response that they were sorry I was having trouble. Tried again today with the same result so sent another email with pictures of settings & indicated temperatures. Guess I'll have to finish this pork butt in the oven & go buy a Treagar Pellet Grill. If Pit Boss corrects this I'll update this review!
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.

Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.

Certain statements in this press release, including statements regarding the expected future financial performance of Camp Chef and the impact of that performance on Vista Outdoor, constitute forward-looking statements as defined in the Private Securities Litigation Reform Act of 1995. The words 'believe', 'expect', 'anticipate', 'intend', 'aim', 'should' and similar expressions are intended to identify such forward-looking statements. All such forward-looking statements involve estimates and assumptions and are subject to a number of risks and uncertainties, many of which are beyond Vista Outdoor's control, which could cause actual results to differ materially from the expectations described in the forward-looking statements. Among those risks and uncertainties are: assumptions regarding demand for Camp Chef's products; the risk that the anticipated benefits and cost savings from the transaction may not be fully realized or may take longer than expected to realize; the ability of Vista Outdoor to retain and hire key personnel and maintain relationships with customers, suppliers and other business partners of Camp Chef; costs or difficulties related to the integration of the business following completion of the transaction; and changes in the business, industry or economic conditions or competitive environment. Vista Outdoor undertakes no obligation to update any forward-looking statements. For further information on factors that could impact Vista Outdoor, and the statements contained herein, please refer to Vista Outdoor's most recent Annual Report on Form 10-K and any subsequent quarterly reports on Form 10-Q and current reports on Form 8-K filed with the U.S. Securities and Exchange Commission.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
This is obviously no revelations that temperature is the first on my list. When it comes to cooking appliances, temperature is always a key factor. However, it is not the sole reason to be on my list. The thing about temperature you need to look for in a good pellet grill is its ability to control, change and maintain it. Any grill can turn screaming hot, but only the best ones provide you with multiple temperature settings, and are able to maintain it constantly to ensure an even cooking surface where it is not too hot on the left and cold on the right. Many pellets come with special, even patented, temperature features.
Pellet grills made out of stainless steel are more durable and rust-resistant and are often the most attractive option. Since many smokers are painted, make sure to research the quality of the paint. A high-temperature powder coat paint can withstand high heat. This is important because if the paint flakes it will leave the steel exposed to outside influences and it could rust.
Z Grills Wood pellet grill and Camp Chef pg24 are mostly different in a lack of an ash removal system or various interesting features. No ash removal system means having to manually clean the grill of ash. It is not a difficult task as the access to the fire pot is easy, but a vacuum cleaner will be necessary here in order to remove the ash fast and easily.
With that said, depending on the size of the green an individual may need more pellets to fuel the food. However, a bigger sized pellet grill allows the cook to grill for a large number of people. While a compact grill can easily be taken anywhere. With that in mind, one important criterion that we wanted to take into consideration is how easy the item is to set up.
Set it and forget it. It does not require you to stay while the food is being cooked as you can set a timer and temperature so you can do other things, like prepare the side dishes or drink beer with friends while the grill is doing its job. Most pellet grills use electronic controls to regulate the grilling according to your preferences. You have a choice to choose the level of smoke aside from choosing your desired temperature.
If you’re looking for very portable smoker on a budget, we recommend the Davy Crockett by Green Mountain Grills. However, if you’re looking for a small backyard smoker that you can use at the occasional picnic, tailgate, or cul-de-sac party, we recommend the Traeger Tailgater. We think the slight increase in cost is justified by the bigger grill space, which comes in handy if you’re using your smoker frequently or to cook for more than two people.
×