Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.
I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
Third name to make it to my list of the best pellet grill review is The REC TEC Wood Pellet grill. It has a trademark Smart grill Technology, which maintains precise temperature. This amazing pellet grill has a whopping 702 square inch cooking area, and a 40 pound capacity pellet hopper. It is made out of high quality stainless steel. It comes with a drip pan.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.

This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)
What makes it stand out from the crowd is that it’s the only pellet grill on the market (so far) that has an ash cleanout system… no more hauling out your vacuum to the patio to suck out the ashes when it’s time to clean out your grill! You just need a small cup… and with a simple turn of a small lever, the ashes drop out! You’ll LOVE this feature!
Cook for a crowd on the Camp Chef® Flat Top Grill! A large cooking area makes it easy to cook efficiently. The interchangeable flat top griddle is perfect for pancakes, bacon and eggs for breakfast, and burgers, chicken and veggies for dinner. Four individual burners make it a snap to cook multiple dishes at once. Built-in matchless ignition lets you control the heat and flame, while folding shelves and roller wheels make transport easy.
OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.

According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
You are eligible for a full refund if no ShippingPass-eligible orders have been placed. You cannot receive a refund if you have placed a ShippingPass-eligible order. In this case, the Customer Care team will remove your account from auto-renewal to ensure you are not charged for an additional year and you can continue to use the subscription until the end of your subscription term.
Feel free to contact us if you need further information or have any question, we will be more than happy to assist you. The Camp O...ven Pizza Stone will cook the perfect pizza anytime, anywhere. Made of Cordierite ceramic fire brick, the Pizza Stone absorbs excess moisture and evenly distributes heat to give a light, crispy, golden brown crust. Cook like the pros where ever you go. Great for calzones too! It fits perfectly in any Camp Oven, most Professional Barbecue Boxes and works great in your home oven. Hihg quality products and best service. read more
Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.
As we started to learn more about pellet grills we realized that we had to take different aspects into consideration when it comes to the quality of the grill. With that said, we are eager to share with our readers the criteria that we used to come up with this top ten list. With this, we can say that all of the grills we share are made of the best quality materials and craftsmanship to be able and withstand the test of time and provide a delicious meal. Other than that, we share this criterion so individuals can find the best pellet grill that suits there needs.

A few other mentionable features are that it has a highly durable temperature proof textures powder coat finish, it features auto start. The REC TEC Wood Pellet Grill accommodates temperatures from 180 degrees Fahrenheit to 500 degrees Fahrenheit with 5 degrees increment. This amazing temperature control features let you be in control of how much heat you want to cook your food in, without having to worry about it getting dry or burnt. This low increment allows you to cook delicate meats like fishes and seafood as well! It smart grill tech makes sure that the temperature you set is always consistent and constant. It also has an “Extreme” smoke feature from the 180 to 250 degrees Fahrenheit setting that intensifies the smoke in the grill.


Compared with charcoal and other wood-fired grills, pellet smokers are simpler and cleaner and easier, giving more control than traditional smokers. Wood pellets are dense, burn hot and smooth, and can be easily fed into the flame with an automatic auger, allowing for consistent temperature with minimal effort. Many modern smokers let you practically set it and forget it, thanks to their digital controllers. Pellet grills are also efficiently cheap, often using as little as 1lb of pellets an hour.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
Now that we have covered the most important criteria to take into consideration when it comes to quality pellet grills, we wanted to share the cost and the value criteria and why we have included this on this list. Now, It is evident that the more costly the grill is, the better quality designed it will be and the better functions it will have. With that said, most grills that are costly have some of the top of the line premiere features available such as high-quality construction that is rust resistant and up to 600sq in. of grilling space.
Create delicious meals with ease with the help of the Camp Chef Griddle (FG-16). It is made out of durable heavy-gauge steel that ...will last for years. The surface measures 14" by 16". This polished steel griddle comes with slightly inclined sides for less mess and it has a convenient carry handle in front that makes for easy transport. This item covers one burner and fits many stoves. read more
3-DFT12 Size: 12" Features: -You can now take the guesswork out of outdoor grilling and concentrate more on the beauty of the grea...t outdoors. -Allow yourself to effortlessly monitor and regulate the temperature of your grill with the Camp Chef Thermometer. Product Type: -Thermometer. Finish: -Silver. Tool Head Material: -Other. Number of Items Included: -1. Dimensions: Overall Product Weight: -1 Pounds. Size 6" - Overall Height - Top to Bottom: -6 Inches. Size 6" - Overall Width - Side to Side: -2 Inches. Size 6" - Overall Depth - Front to Back: -2 Inches. Size 12" - Overall Height - Top to Bottom: -12 Inches. Size 12" - Overall Width - Side to Side: -2 Inches. Size 12" - Overall Depth - Front to Back: -2 Inches.Package Quantity : 1 read more
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
You want to easily switch to different smoky flavors: Changing flavors in your Traeger grill is as easy as changing the pellets that you place in the hopper. Through its website, Traeger offers several different smoky flavors of hardwood pellet offerings, including hickory, mesquite, apple, maple, cherry, and oak. And Traeger’s website provides information on which types of hardwoods provide the best smoky flavor for certain types of foods, which can help you successfully use this grill immediately out of the box.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
It uses only all-natural cooking-grade wood pellets for fuel. NO gas, propane or charcoal. Built to last and designed to deliver immediate success. The easy to operate Digital Control Center dial-in control gives you complete control from 170 Fahrenheit to 600 Fahrenheit. An electric ignition and fan-forced air accelerate and maintain a clear burning flame for an abundance of convection heat and clean, flavorful smoke. The 'Flame Broiler' allows for both 'Direct' and 'Indirect' cooking while adding flavor back to your cooking and channeling excess grease away. With the amazing versatility and flavor of real wood cooking, our Pit Boss Pellet Grills will allow any new or aspiring backyard cook to smoke ribs, jerky, fish; bake biscuits, pizza; Grill burgers, vegetables, or sear or charbroil a steak with confidence, every time.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor. 

This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
Keep your Pellet Grill and Smoker fired up Keep your Pellet Grill and Smoker fired up with Camp Chef’s Premium Hardwood Pellets. Made of 100% natural hardwood these food grade pellets are an excellent way to add that unique smoky flavor. Choose from 4 distinct flavors. Smokehouse Hickory impart a rich and smoky bacon-like flavor to all meats ...  More + Product Details Close
I did a lot looking around at pellet smokers before buying the ys 640. This thing is amazing! I have been cooking BBQ for about 15 years. I owned a Gator pit entertainer which is made in Houston Texas (stick burning pit) and I currently own a $25,000 Ole Hickory Pit EL-EDX which can cook 700 lbs of BBQ at once. I wanted something smaller to cook for family. The ys 640 turns out PERFECT Q every time! The amount of smoke is just right. Plenty of smoke flavor without over smoking which is very easy to do in my other pit. This is an EXCELLENT product which I strongly recommend.
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.

Their behavior is sometimes counterintuitive. The hotter they get, the less smoke they produce, and at their top settings, they don't produce much smoke at all. This is good for when you are baking cakes or pies or doing dishes that don't need smoke. But down under 250°F, they produce plenty of mild, elegant smoke. And even though the fuel is wood, it is hard to oversmoke with a pellet smoker. Burning wood on a charcoal grill produces much more intense smoke flavor.


The Smoke Pro SE Pellet Grill brings award-winning barbecue to your back patio. Simply select the desired cooking temperature and ...let the smoker do the rest. Our Smart Smoke Technology maintains a consistent temperature range to produce as much smoke as possible. That means the best flavor possible. And at the end of the cookout, you’ll enjoy the easiest, quickest cleanout system in the industry. Instead of dismantling and cleaning your grill after every use, you can pull a lever and empty the ash out of the fire pot. In a few seconds, you’re ready for your next big barbecue. And it’s good thing too, because that smoky taste is going to keep everyone coming back for more. read more
's 10" Seasoned Cast Iron Skillet is a great addition to your camp essentials. Its ready to use right out of the box with its " Tr...ue Seasoned" finish that's healthy to cook with and easy to maintain. It features a comfort grip handle for easy lifting and control and dual pour spouts for cooking convenience. BTI trading was established in year of 2012.We are allocated at US WA.The transportation to our store is very convenient.we are selling only high quality products we also selling our products world wide .At BTI we sure you can find all the product that you want. read more
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
Multi-position and digital controllers ( LED display ) - a much better solution, but it does have its flaws. First a multi-position controller, then a digital controller that allows to set the temperature at intervals of +/- 25 degrees F. It’s a controller that also has poor responses to weather. A great advantage of a digital controller is that it allowed to implement other innovative solutions. It helped introduce such technologies as alerts, timer or better meat control.

This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
It is great when it comes to smoking meat at low temperatures, regular grilling, baking or roasting. You can have problems, though, if you want to sear your meat, it requires much higher temperatures. Sadly, a regular pellet smoker cannot reach them. In that case look around for a pellet grill that comes with an additional sear box that is gas fueled and can heat up to 900 degrees F.

This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.


Just what I needed for my Traeger Pro 22. Fits like a glove, simple install, and makes adding and pulling rib racks off the smoker much easier. No longer a balancing act trying to get a tray to stay put on top of the pellet hopper lid. This also fits perfectly under Traeger's cover for the Pro 22 models. Have to be a little care you dont pinch your fingers when folding it down (would be a nice future mod if it could somehow be spring assisted), but thats my only gripe.

Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.


What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.

I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
×