I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?

Not only do cheap grills not hold up as well, but there are additional benefits to better steel and construction, too. Construction quality matters in wood pellet grills, no matter the price. Take the video below where we compare Grilla Grill’s double wall insulation to Camp Chef, which is not a cheap grill by any stretch. This video shows how well the Grilla Grills pellet grill is able to retain heat, keep the cool out, and use less fuel than many other wood pellet grills. Now imagine how much difference this would make compared to a bargain basement pellet grill from a big box store!
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.

REC TEC pellet smokers appeared a few years ago and the makers wanted to make their grills stand out. They wanted a grill that would have the type of temperature control found in an oven. Logically, this meant a pellet grill. But the REC TEC RT 680 isn’t revolutionary – it has a great marketing campaign, strong following and committed support. The makers even provide a 30-day no questions asked return policy and a six-year warranty.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.

As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.
Lauded for its amazingly accurate cook temperatures and times and for affording cookers a real “unfair advantage” at competitions (according to those who lose to them) — Fast Eddy’s Cookshack Pellet Smokers rank among the very best available on the market today. I love the history of Fast Eddy’s pellet smokers. In 1986, Ed Maurin (Fast Eddy) — a retired KCMO Fire Fighter — cooked his first American Royal event. From that point on he was hooked on BBQ and on coming up with the very best way to ensure its production. By 1998 the first of his Fast Eddy’s pellet smokers was released to the market, and he was off to winning competitions and helping those who bought his cookers do so as well.

I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.


One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
Main products of our company :electric, home,toy,clother ,etc. Since its foundation ,the company keeps living up to the belief of ...:"honest selling ,best quality ,people-orientation and benefits to customers. "We are doing everything to offer our customers with best services and best products .We promise that we'll be responsible all the way to the end once our services begin DECENT FEATURES of the Steel Griddle 14" x 16" Covers one burner Convenient carry handle Polished steel The SPECS Box Dimension: (L x W x H): 16.5 x 16.5 x 1.5" Box Weight: 12 lbs This product can only be shipped within the United States. Please don't hate us. If you have any further questions, please feel free to contact us. We look forward to serving you in the future. read more
When it comes to spending your own hard-earned money on a new wood pellet grill, you want to invest in a product that is going to last you for a while. There are many differences between purchasing a cheap wood pellet grill and a pellet grill that is built with quality materials. Even though the cheaper grill may be easier on your wallet in the short run, the long-term costs will quickly outweigh the initial savings. So, if you’re thinking of buying a cheap pellet grill, continue reading to learn about the true costs that could be associated with your decision.

Traeger makes this process very easy. All you have to do is add pellets, open the lid, turn the knob to smoke and that’s it. The hopper will automatically feed pellets over a hot rod and ignite the fire. You should have your smoker up and running at 230°F in less than 10 minutes. All you’ll have to do after the Traeger 34 Elite smoker starts up is add meat and make sure you don’t run out of pellets.
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.

The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.


I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.


I love the taste of smoked food. I have now tried, ribs, turkey, chicken, and steak on my traeger grill and would have given them one star if not that smoked meat taste great. Everytime i use the grill, something that isn't supposed to happen, happens. I have to go out and check the pellet hopper every half hour to make sure it doesn't just use the pellets in the middle, so I have yo mix them around. Even when I do that, I can have the grill set for 225 and it goes up to 400-500 degrees or catches fire. Then when I restart it, it sometimes cools down to below 150° and shuts down in the middle of my smoke. I'm very dissappointed because the grill was not cheap, the pellets aren't cheap, and the food I am.ruining isn't cheap. I know traeger isn't going to do anything about it because I have called and they gave me "reasons" all of these things happen, and they already got their money from me but I am hoping I can deter as many people as possible from overspending on a defective grill. I really do wish it was a good product because I don't have the money to buy another.

Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.


Loved the idea of a "pellet smoker" - less stress, delicious meat. Bought mine at Costco 1 year ago and have used it many times with mixed results, not exactly stress less. Last time using it the pellet hopper caught on fire, turns out the auger chamber is packed full of pellets and won't move. Attempted to open chamber to clear and with this model it is extremely difficult (with unit sold thru Costco - newer ones look easier...) so I called customer service hotline. Called different 4 times and talked with a different live person each time and was promised a call back to schedule an in house repair. Never received one call back so I tried to email and again never received a return email. I have no choice but to return smoker to Costco.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.

You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
Main products of our company :electric, home,toy,clother ,etc. Since its foundation ,the company keeps living up to the belief of ...:"honest selling ,best quality ,people-orientation and benefits to customers. "We are doing everything to offer our customers with best services and best products .We promise that we'll be responsible all the way to the end once our services begin DECENT FEATURES of the Steel Griddle 14" x 16" Covers one burner Convenient carry handle Polished steel The SPECS Box Dimension: (L x W x H): 16.5 x 16.5 x 1.5" Box Weight: 12 lbs This product can only be shipped within the United States. Please don't hate us. If you have any further questions, please feel free to contact us. We look forward to serving you in the future. read more
Pit Boss wood pellet grills make it easy to prepare and serve the finest in wood-fired gourmet goodness. Using 100% all natural cooking-grade wood barbecue pellets for fuel, no gas, propane or charcoal is needed! turn a simple dial to start the grill, and you can sear a steak, bake pizza or cookies, smoke jerky, ribs or brisket, all with natural flavored wood pellets. With a dynamic range of cooking temperature from 180 degree to 500 DegreeF, you have complete control with the turn of a dial. The digital control board, along with the oven-like meat probe, result in precise cooking control. Fan forced convection cooking seals in meat juices and eliminates the need for a rotisserie. The 340 is the smallest in our pit boss wood pellet grange. But it doesn't hold back. It still offers all the great benefits of a pit boss wood pellet grill, just in a smaller package. This is perfect for a small family that wants that 100% natural wood pellet flavor.
Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.
Camp Chef is proud to expand it's tradition of creating the finest cast iron cooking products with the introduction of the 12 Inch... diameter deep Dutch oven. What does that mean? It means that the most popular Dutch oven size can now feed even more people, cook a standing rib roast or bake the largest cobbler you've ever seen. We use the same tried-and-true methods from the other ovens in the classic line. True-seasoned cast iron comes ready to cook right out of the box. Even wall thickness, large carry bail and superior quality control is what separates this oven from all the other out there. If you a black-pot junky or just beginning this is the one that will quickly become a favorite. This Dutch features three legs, a handled lid and bale. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood.Total Weight = 25 lbs.Depth: 5 InchCapacity: 8 QT.OD = 12 3/8 InchModel No: SDO12DUPC Code: 033246209418 read more
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
The “Smart Smoke” controller goes from 160-450F, with an internal sensor and electric auger maintaining that heat. The hopper holds a good 20lbs of pellet - enough for 10-20 hours of smoking. And it’s built from a sturdy stainless steel that feels solid and looks fantastic, with locking caster wheels keeping it secure while in use. It’s also backed up by a 3-year warranty.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.
First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
Novices: Do you consider yourself a novice with a smoker grill? If so have no shame, in fact, look at me, I started as a novice too! Realistically, no one becomes a geek in 2 weeks of studying or research. So as a beginner you must look for an easy to use smoker grill. Well, the primary concept of a pellet smoker lies in its easy to use features. Set it and forget represents the motto and the main aspect you crave, right?
It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
Less smoke and less heat – Pellet burners do not produce a strong smokey flavor like stick burners, for example. As we mentioned earlier, they also do not reach the same high temperatures as other types of grills, so you cannot expect great sear marks either. Some model like the Camp Chef PG24 Deluxe let you get around this by purchasing a sear grill attachment.

When you are looking for a smoker, one of the features that you want is to be able to control the temperature. This means that you will be able to use both a high and low temperature for smoking everything from poultry to fish to beef to vegetables to cheese. This is exactly what you get with the Camp Chef. It has an LED digital temp control system that comes with a food probe made from stainless material.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!

The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
The Camp Chef Camp Table is the perfect companion to any table top stove or dutch oven. The camp table will hold two 14 inch dutch... ovens and provides extra preparation and serving space to keep your food up off the ground. Works great with the Mountain Series stoves from Camp Chef and is a great accessory piece to your free standing stove. Side shelves* (Model LS60P) can be added for even more space. read more
For example, many grills use and charge for collaborating with a software application on it. I, personally, think this is an absolutely silly feature to include on a pellet grill. Yes, it does start on and off from your phone and change temperatures while you are at Switzerland enjoying Swiss cheese on a lake, but really, is it even logical? I mean, pellet grills have already made the cooking experience as easy as a dream, the least you can do is set the temperature by the click of a button on the appliance yourself! You can’t possibly be that lazy!
I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.

This review is just a repeat of many already submitted.  Got my Traeger Elite 34 this summer at a trade show.  It would not get up to temperature, wouldn't go about 360deg with food inside.  Empty it would hit 390 max.  Most of the 'infamous' Traeger recipes call for 400+.  If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover.  I called Traeger and they claimed their grills 'never do this'.  After reading dozens of reviews since, the truth is that they seem to 'usually do this'.  The big grilles just do not have enough BTUs to heat up properly.
I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.
So what about the question of blends versus 100% pure species pellets?  Should you avoid blends?  Should you only use 100% pure?   That is a web to unweave and depends greatly on what you are cooking as to the correct answer.  Through our testing we found many blends to work very well.  We liked them so much that we incorporated them into what we offer.  Not all blends are created equal though and the amount of hardwood versus flavor wood varies widely across brands.  We also found that some 100% pure pellets such as cherry and apple had harder times reaching higher grilling temperatures and lacked the harder core flavor punch of hickory or mesquite.  Coming from the world of stick burners many new pellet grill owners assume that going 100% cherry or apple is going to work for them since that is what they have grown accustomed to.  At the end of the day, they end up moving to a pellet with a deeper flavor like hickory or mesquite to get the results they are used to.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
Thanks for the great information and the research you did. I am a retail store owner in Boise, Idaho area and we sell a pellet grill smoker in our store. I would like to encourage to look at the Sawtooth Pellet Grill. It is made local here and is American Made. It is an excellent grill for the price with an awesome company backing it. You can find their website at sawtoothpelletgrills.com. Again thanks for the information and if you do another publication regarding pellet grills, I would love to see what your opinion of the Sawtooth would be 🙂
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.

This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.


My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
Some products feature the wood-pellet fuel system as a bonus, but the Camp Chef SmokePro SG makes its wood-fired function the star of the show. Using 100% real hardwood pellets, recreating 5-star-cuisine level dishes on a large scale is now made convenient. Though it still has limited reviews, it wouldn’t be a surprise if this smoker quickly becomes a best-selling choice. It’s the kind of smoker that you need if you want hassle-free and fast cooking.
Each grill is porcelain coated, like you’d find on professional grills, for exceptional heat transfer and easy wipe cleaning. This attention to excellence is extended over the whole machine, with everything made out of heavy gauge steel and top quality material. The only real let down is the wheels, which are kind of low quality, but they’re real simple to switch out.
Entertaining a large group of people at the barbeque party becomes easy with the Camp Chef Yukon YK60LW 2-Burner Stove. With a coo...king surface of 448 square inches, this camp stove makes it convenient for you to cook for a large or small group of people. This Camp Chef two-burner range stove has removable legs to make for convenient portability - take it along for your camping trips or simply use it for your other outdoor cooking needs. Appliance-style control knobs let you have complete control over the flame, whereas the 3-sided wind screen helps protect the flame from wind. This portable camp stove also comes with a hose and regulator for added convenience. read more
One thing I’ll mention up front is that the Rec Tec Grill is not sold as a Made in America product. The REC TEC Grill is made in China, however, the heart and soul of the grill (the computer) is made here in the USA. The powder coat is also made in the USA and the final assembly along with quality control takes place at the REC TEC Grill facility in Georgia.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
×