Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.


Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.

I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."
Regarding your question about a decrease in smoke flavor when using the pellet grill / smoker, I do believe you will experience a little bit of a drop off. This said, many people find the flavor from pellet grills / movers to be adequate. If you require a stronger smoke profile, you can always use one of the tube smokers that sits inside of the cooking chamber.
I'm using a ThermoWorks "Smoke" thermometer to send smoker temp info while I'm busy doing other things. So much easier to set it and not having to worry about it compared to grilling over charcoal (although I still like to do that for high temp California "BBQ"). Just come back when it's close to being done to give a quick visual check compared to the probe temperature. May consider adding the sear box in the future.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.

Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.
Not only do cheap grills not hold up as well, but there are additional benefits to better steel and construction, too. Construction quality matters in wood pellet grills, no matter the price. Take the video below where we compare Grilla Grill’s double wall insulation to Camp Chef, which is not a cheap grill by any stretch. This video shows how well the Grilla Grills pellet grill is able to retain heat, keep the cool out, and use less fuel than many other wood pellet grills. Now imagine how much difference this would make compared to a bargain basement pellet grill from a big box store!

Today I grilled up a T-Bone steak. And I used the Grill Grates. I upped the temps to 600 degrees. The T-Bone came out FABLULOUS!!! Actually, it cooked faster than I expected, and the sear marks were way better than I expected. I have been using Weber Gas Grill for many years and way satisfied with the results, but the Yoder smoker kicks ass...BRAVO YODER!!


With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.
Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.
Traeger Junior Elite Pellet Grill is a great model for those who want to start up the smoker, add some meat, and let the work be done for them. It is also extremely versatile, allowing you to grill, smoke, roast, and bake. It is perfect for individual households, college students, and even tailgating. And it’s a great option for first timers as well as those who have experience using pellet smokers.
We all know about Davy Crockett and Daniel Boone, but Traeger is the true pioneer of pellet smoking. This company introduced the first pellet smokers, and it remains the best-known brand, although competition is growing. There's nothing fancy here. Instead of a touch-pad controller, Traeger employs an older-style digital dial controller. No WiFi or meat probes; just no-frills schmokin' from the industry leader.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
I’m not sure of the dates on the above replies, its now Oct.2017, and I’ve had enough of the Bradley dig. smoker. I live on Long Island NY and the Bradley has trouble getting up to and holding temp. I’ve added a PID to it but have decided to take it up a level. I’ve done a bunch of research and I’m leaning toward the Yoder 640 with Comp. cart. unless you take me out of it. What would you be spending your money on today? I did buy a book though your site, I hope that helps.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.

Rec Tec Wood Pellet Grill boasts a cooking area of over 1000 sq. inches. However, that area is calculated from its optional cooking shelf. Without it, the cooking area is roughly around 700 sq. feet. This removable shelf can allow you to increase your cooking area if you’re trying to cook patties, steaks, chicken pieces and items as such; or they can be removed for granting a greater volume of space for smoking brisket or whole turkeys.

×