GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.

Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.

I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 


For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
Grill delicious sandwiches or sear your favorite meats to perfection in the great outdoors with this versatile Camp Chef 11" Squar...e Skillet with Ribs. It is made with 100 percent pre-seasoned cast iron and features a square design. This Camp Chef skillet is equipped with a pour spout on each side, allowing the user to easily drain off excess liquid and fat. In addition, it features a long handle on one side and a small handle on the other, making it a breeze to maneuver and transport directly to the table. Ideal for campers and tailgaters, this ribbed pre-seasoned skillet is easy to clean for added convenience. read more
Simply browse the product categories that interest you. Once you've located an item to order, click on the "Add to Cart " button. You'll immediately be taken to the "View Cart" screen where you can verify the item you have selected, remove the item or adjust quantities. From the view cart screen you can either continue shopping and select additional items or checkout.

Save up to $100.00 on select GMG Grills during the Green Mountain Grills 2018 Holiday Sale.  Shop America's largest online selection of Green Mountain Pellet Grills during the GMG Holiday Sale including Green Mountain Daniel Boone Grills, Davy Crockett Portable Tailgate Grills, Jim Bowie Pellet Smokers, Premium Green Mountain Grill Wood BBQ Pellets, GMG Grill Parts, Green Mountain Grill Pizza Oven Attachments, and much more!  Call Toll Free:  888-313-2737 to speak with an Authorized Green Mountain Grill Dealer Today!
Yoder YS 640 is built out of durable materials. Unfortunately, this means that it is heavier than some other units. It weighs 325 lbs, nearly twice as much as the Traeger Texas Elite 34. The main body is built out of 10 gauge metal. It will take more time to reach the highest temperature, however the smoker will hold the heat in far better than some other cookers.
We got one of these a few months back and are so happy with it! If you want a pellet grill but don't want to fork out hundreds of dollars for a Traeger.. Then this is the way to go. We have the smaller one and it's perfect for the two of us. But we have put a pork loin, 2 pans of bacon and 2 baked potatoes on at once and it all came out perfect. Baked potatoes on this grill are AWESOME. We love pork loins on it as well! We have yet to try hamburgers or something simple, as it turned winter here suddenly but it is great for what we have used it for!
Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.

The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.

The Camp Chef Wireless Food Thermometer works very well with Dutch ovens, smokers and grills. The wireless food thermometer featur...es a 100-foot wireless range, an elapsed cooking time feature, and a stainless steel probe with a 48-inch lead. It is an excellent accessory for entertaining, because it allows you to monitor the temperature of your food without leaving your guests. This Camp Chef Wireless Food Thermometer is a compact and simple-to-use device. The wire and probe are both rated for over 475¿¿F, and the base is equipped with an LED light in the front for easy viewing. The Camp Chef wireless thermometer provides suggested cooking temperatures for six types of meat, and offers four distinct taste settings. read more

Compared to the Traeger Pro and the other smokers we’ve reviewed, there’s not much not to like about this bad boy. It’s significantly cheaper, packs ample cooking space, and a good, consistent temperature controller. At 173 lbs, it is quite heavy, and not at all portable like the Davy Crocket, and we’d love to see it come with more precise temperature control, and maybe even WiFi in the future. But for the price, it’s a beast of smoker that is almost as good as the Traeger.
One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 
I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
Ready for the camp or cabin, this reliable, no-frills stove features two 30,000-BTU commercial-grade cast burners. The all-steel range features sturdy grates built to support hefty cast-iron cookware. It's surrounded by a three-sided steel screen to block drafts and grease splatter. The heavy-duty steel legs slide off for transportation and storage. Cooks up to 15 hours on a 20-lb. propane cylinder (not included). Includes hose and regulator.
Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.
Barbecuing and grilling meats to the perfect temperature, texture and doneness is a skill that is acquired over years and years of practice. There is a lot that goes into making a good BBQ than just good seasoning and fresh meat, and any pit master will agree. There are just so many aspects you have to learn how to control: the temperature, the smoke, the placement, the ratios and so on. But you are lucky that this is new of yesterdays.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy

Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born from love of crisp brick-oven style pizza. It’s been designed with the cooking ability of professional brick ovens but with the accessibility ease and size of a portable grill. Whether you’re holding an impromptu family pizza night inviting the friends over for ...  More + Product Details Close
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
The fight for building the cheapest pellet smoker with decent quality is pretty intense. Unfortunately, a cheaper pellet grill often leads to lower quality construction. The Camp Chef SmokePro DLX is more expensive then the Pitboss 71700fb, and in our opinion the Pitboss is the better pellet smoker. It isn’t a bad unit; the controller of this smoker even includes a meat probe which typically comes only with the more expensive units. However, it does have one flaw – the lid.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.

The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish. 

Apart from the replacement parts for a pellet smoker, there are also certain accessories that one can use to increase the range of its usefulness as well as improve its performance. A user can attach a griddle attachment to a pellet grill to use it as a flat top griddle, or use a hopper extender to increase the pellet hopper capacity; there is an attachment for every purpose to suit all of your needs. Let’s take a look at the types of accessories commonly found:
×