Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.


Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?

You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.

RT 700 offers a Front Folding Shelf and has its own set of meat probe to monitor meat temperature while the grill smoke is infusing with the meat. Its Stainless Steel body protects it from rust and the colors from cracking or peeling. With its built-in WiFi-enabled control, coupled with Rec Tec’s proprietary PID algorithm, you will have control over your cooking process remotely using your wireless devices.
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.

The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.


The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
In the Grills Bull we have another large, unwieldy, but fully loaded grilling system. With a price that would make most grillers wince, this Pellet Grill comes complete with all sorts of bells and whistles. Aside from the large, wifi-enabled grill itself, Rec Tec throws in a terrific 6-year warranty as well as over 150 pounds of Pellets, which goes a long way towards justifying the cost. The Bull also has a large, 100% stainless steel cooking space which offers terrific durability long-term.
I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Hey Shannon – they all have their merits. Budget dictates a lot. If you’re in the $1000 or under range, Green Mountain and Rec Tec are great choices. Both have developed near cult followings, with GMG a little ahead of the curve on that front having been around a bit longer. I love the Yoders as far as moving up on the price range is concerned. Will last you forever and they offer a solid product with great support. MAK grills are just beautifully made. There’s no other way to put it. The “General” models are superbly crafted. Love that MAK offers built in cold smoking as a capability. Am I helping here or just making things worse? Hahaha.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.

For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT 

I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
So what about the question of blends versus 100% pure species pellets?  Should you avoid blends?  Should you only use 100% pure?   That is a web to unweave and depends greatly on what you are cooking as to the correct answer.  Through our testing we found many blends to work very well.  We liked them so much that we incorporated them into what we offer.  Not all blends are created equal though and the amount of hardwood versus flavor wood varies widely across brands.  We also found that some 100% pure pellets such as cherry and apple had harder times reaching higher grilling temperatures and lacked the harder core flavor punch of hickory or mesquite.  Coming from the world of stick burners many new pellet grill owners assume that going 100% cherry or apple is going to work for them since that is what they have grown accustomed to.  At the end of the day, they end up moving to a pellet with a deeper flavor like hickory or mesquite to get the results they are used to.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.

It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.


Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Temperature range is an important factor. What you’ll need will depend on what kind of cooking you want to do. Top pellet grills can hit temperatures between 180 F to 425 F, enough for baking, smoking, roasting, and grilling. On the other hand, ioif you want to sear meat you need something that reaches the 500-550 F range. A functioning thermometer is a must. You’ll need a precise and accurate reading so you’ll know you’re cooking your meat at the right temperature.
Generally speaking cheap grills are not made with quality materials. While the outside may look good, often times you will find the guts of the grill are made with lower grade metals. This of course affects functionality and longevity. If the inside of the grill isn’t made using quality materials you will literally burn through it over a certain period time.
After 10 days of not seeing anything in my email I called them. They told me they had no order. After two weeks and more phone calls then a grill finally shows up but without the cover or the pallets which I paid for and was on the order. Three calls into managers and customer service still not resolved. When I threaten to take the grill back to Costco I was told to go ahead and have a nice day.
But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
True blooded grill sweethearts out there might value this item. It is a minimized, full-included pellet barbecue that can take care of their grilling needs. You may need the item that accompanies all that you may require. When you have warmed it up, you can anticipate a perfect temperature and warmth in view of what you have chosen. Much the same as when you have found a reasonable latte machine for you, you would feel pleased with yourself for picking an extreme item that stays aware of your needs. Another element you may acknowledge in the item is that can keep the correct temperature all through the barbecuing or cooking process—regardless of whether you burn, grill, smoke or prepare. The cooking instrument is an exact griller that won’t make you stressed over any temperature variance. So whether you are an amateur or a pit ace, you might need to investigate this item that can take your grilling to the following level.

I cannot comment on the quality or Function of the Grills as I never received mine. I order a Texas Elite 34 at the Minnesota State Fair on Aug. 23rd for $899 with a few extras and was told this was the lowest price ever (Not True). They did not tell me about the pro series which I found later. They said it would be delivered within 7 days. 2 weeks later no grill so I called customer service just asking on when I would get the grill. They could not find my order and did not believe I ordered one... They said I had to email them my receipt as they could do nothing on the phone.

Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.


I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.

The construction and the elements - REC TEC  Pellet grill are an investment for years, safe from corroding. Most of competitive  grills look pretty on the outside and the manufacturers claim they are made of stainless steel. The truth is, only the outside part of the grill is stainless. The steel on the inside is different, and major parts are made of materials of poorer quality.

4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
 When you think of a pellet smoker, what comes to mind is the rich taste of BBQ, better manipulation and convenience. These are exactly what the best pellet smoker should give you. To find out the best, among the many out there, you should think of various features. A burner that can give you control, comfort, long service, and great flavor in food is something a top rated pellet smoker should have. Let’s take a look at all the factors you should consider when making your purchase.

DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork


Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.


This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.
A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.

Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:

Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.

© Copyright 2005 to 2018 by AmazingRibs.com. All text, recipes, photos, and computer code are owned by AmazingRibs.com and protected by US copyright law unless otherwise noted. It is a US Federal crime to publish or distribute anything on this website without permission. But we're easy! We usually grant permission and don't charge a fee. To get permission, just click here. And you don't need permission to link to us.
A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
×