This maker of top-quality wood and pellet grillers is the company spearheading the digital revolution in the pellet smoker industry like its digital controller that manages pellet flow to control internal temperature and WiFi that connects your phone to the grill, allowing you to use it to control your grill for good measure. It’s the more gimmicky of the different pellet grill makers.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.
It’s capable of many of the same feats as its sibling grill and other top-rated competing grills, but its piece de resistance is its Smart Grill Technology that allows you to control the temperature as easily as conventional ovens. Just don’t let it sit in direct sunlight and muck up its temp. The bottom line with this “smart” grill is that it has more pros than cons.
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
Many people misunderstand a pellet grill of consuming a large amount of power for its working. But it is not even remotely true. While it is true that a pellet grill will use up a good amount for power initially, but it only uses that to come to temperature and form. Once it is ready and in form, it power consumption drops so dramatically that some pellet grills use almost as little power as a light bulb; an ideal choice for keeping power costs to a minimum.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?

Another avenue that many pellet grill owners use is participating in a bulk buy of their favorite brand.  Many times by ordering as little as a thousand pounds of pellets and having them shipped via pallet can save enough per pound to be worth the effort.  Also, check the websites of the pellet brands listed above, many have local distributors that maybe with an hour drive of your location.  If you are new to the pellet world, the thought of ordering a thousand pounds of pellets may sound excessive or intimidating.  Many felt this way at first, but if you are in a location where it is hard to get pellets, the mantra of keeping at least a hundred pounds of pellets (five 20 pound bags) on hand at all times starts to make sense quickly.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
Hi there i want to recommend the CAMP CHEF pellet smokers you get the bang for your buck with these smokers i know a lot of you out there are turning up your noses but these smokers have all the extras at a very good price well under a $1000 customer service second to none you get the pellet clean out in the hopper they have a ash tray under the body you just pull a lever and all your burnt ash is cleaned out digital temp for the food digital temp for the chamber lo smoke and high smoke setting and it goes up to 500 degrees at 25 degree increments mine coast me $359 out the door includes shipping it dose a wonderful job holding the temps with a 10 to 15 degrees swing i bought mine at CAMP SAVER.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
The Camp Chef Collapsible Garbage Can is a handy container for removing leaves, cleaning up after parties or for use on camping tr...ips. This camping garbage can contains spring-loaded setup for fast and easy use. Two plastic toggles keep it collapsed for transportation and storage. Made from Polyethylene construction with metal coil support, this collapsible garbage can is rugged. The 35 Gallon Garbage Can provides for cleaning up a large area without having to stop to dump in between. Featuring dual carry handles and a built-in zippered lid, this garbage can is convenient for tailgating, backyard barbecues and more. read more
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
Between me and my dad we've smoked on many different types of smokers- Lang 60 stick burner, green egg, Weber smokey mountain, Stump's vertical feed. To be perfectly honest, using those you might be able to get slightly better results (perfect bark, smoke ring etc) but at a much higher cost and much much more effort. If you're cooking for family cooking and fun this smoker will produce delicious BBQ just short of competition level but much better than almost any restaurant. If you'd rather turn a knob and drink a beer instead of starting fires for logs or charcoal and still get 90-95% results (I'm a BBQ snob) buy this!

Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.

I purchased a Traeger Elite Grill from the website. I use the grill one time and it worked fine. A couple of weeks later we fired up the grill to cook some steaks. Approximately 10 minutes into cooking the auger stopped working. We had to finish our meal cooking it on the stove. I looked at the troubleshooting guide and the steps needed to be taken. To determine what was wrong you basically needed to dismantle the electric box and auger housing. I am not an electrician Nor a mechanic and feel this is excessive for a consumer to have to do.
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.
Louisiana Grills is a respected brand when it comes to pellet smokers. It was one of Traeger’s earliest competitors that entered the market after the original Traeger patent expired. The biggest difference between the two brands is that Louisiana Grills makes pellet smokers with advanced features for a relatively affordable price. The Louisiana Grills LG700 is no exception. It has a one-touch PID controller, a programmable meat probe, an adjustable flame broiler for direct grilling, an upper cooking rack and a lower storage shelf.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Recently bought portable Traeger ptk+ smoker as camp a lot. Food is amazing though grill size better suited for 2-4 ppl and you can’t fit a large roast. However cooked a rack of ribs, several chickens and burgers. Food comes out amazing. You do need electricity hookup camping and it drains too much power to run off cars dc socket. $300 and of you call them to order v online they will throw in free weather cover free shipping and some rub. It does take up some room in car so beware if you have tiny vehicle. Buyer beware racoons love smoked food so remove your trash bag with bones from campsite before retiring, as we found out the hard way

So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?

JUNK!!!!! Major defects and powder coating coming off and possibly getting my family sick. Very rude customer service telling me to just take it back to Costco! Did I mention I bought the biggest one and will need to disassemble the entire thing to fit it in my explorer! I will be sending the paint chips that came off to a lab to determine what the stuff is and if my family has been exposed to carcinogenic chemicals. A $1,000 for Chinese junk....Stay away for your families sake!!!!!
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase. 

With that said, we also wanted to take into consideration the smaller grills of the family. For instance, we wanted to share pellet grills that were intended for portable use or individuals that want a small smoker that is of the best quality. As far as cost and value are concerned, we can say that all of the grills on this list are top of the line and have expert quality features that make them ideal for the individual that wants their ideal pellet grill.
Convection is achieved using a number of techniques. Air is fan forced into the grill and channeled throughout by our arched flame broiler. Our exhaust design allows air to circulate evenly along the length of the grill and to the top shelf. This combination allows us to achieve uniform heat throughout the unit whether your smoking at 170°F or cooking all the way up to 600° Fahrenheit.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.
Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.
Pellet grills are every lazy man’s dream appliance. These grills need absolute zero to minimal maintenance. You just need to lightly wipe through it after every use, and maybe thoroughly clean it 2 to 3 times a year! All pellet grills now come with a drip pan that catch the accumulating oils that drops from the food. They are also made with good quality raw materials that enable them to withstand the outdoor atmospheres all year round. If this does not entice your lazy bones, no other appliance will, and that is a fact. Period!
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
The Camp Chef Camp Table is the perfect companion to any table top stove or dutch oven. The camp table will hold two 14 inch dutch... ovens and provides extra preparation and serving space to keep your food up off the ground. Works great with the Mountain Series stoves from Camp Chef and is a great accessory piece to your free standing stove. Side shelves* (Model LS60P) can be added for even more space. read more 

As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.

***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
Hey Bill! I think you’d be very happy with a Yoder pellet smoker. From a product and manufacturing standpoint, they’re great pellet smokers. If you’re looking at spending $1,700 and can perhaps go a little higher, you can then consider either a MAK grill or a Memphis Grill Pro Series. These are fantastic pieces of equipment. They are insulated at the point where the lid touches the body at closing, and provide superior convection cooking. Anytime you feel you want some extra smoke, you can always throw in an Amazn Pellet Tube or use a Mojo Cube. These will amp up your smoke profile in a manner you can predict and keep under control. I would NOT recommend adding anything foreign to your burn pot ever. Just keep things from the main pellet smoker function working as per the manufacturer’s design.

Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.


My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
×