PID Controller – one of the best controllers. Precisely maintains the temperature you set at intervals of +/- 5 degrees. Perfect when it comes to long and slow meat smoking at low temperatures. You can leave such a pellet grill for the entire day without worries and forget about it. When coming back after many hours, you’re sure that your meat has been cooked at the fixed temperature that you set.
PID Controller – one of the best controllers. Precisely maintains the temperature you set at intervals of +/- 5 degrees. Perfect when it comes to long and slow meat smoking at low temperatures. You can leave such a pellet grill for the entire day without worries and forget about it. When coming back after many hours, you’re sure that your meat has been cooked at the fixed temperature that you set.

Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.


Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/
Pit Boss wood pellet grills make it easy to prepare and serve the finest in wood-fired gourmet goodness. Using 100% all natural cooking-grade wood barbecue pellets for fuel, no gas, propane or charcoal is needed! turn a simple dial to start the grill, and you can sear a steak, bake pizza or cookies, smoke jerky, ribs or brisket, all with natural flavored wood pellets. With a dynamic range of cooking temperature from 180 degree to 500 DegreeF, you have complete control with the turn of a dial. The digital control board, along with the oven-like meat probe, result in precise cooking control. Fan forced convection cooking seals in meat juices and eliminates the need for a rotisserie. The 340 is the smallest in our pit boss wood pellet grange. But it doesn't hold back. It still offers all the great benefits of a pit boss wood pellet grill, just in a smaller package. This is perfect for a small family that wants that 100% natural wood pellet flavor.
One final word of caution when it comes to pellet pricing.  If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it?  What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day?  We are all for saving money as much as anyone, but perspective is key here.  We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.

Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazonhttps://tinyurl.com/amazingribs
This smoker offers a decent 418 square inches of grilling space. This is enough to cook around sixteen burgers or four whole chickens. If the grilling space isn’t enough, Traeger also offers a larger unit that offers the same features at a higher price range. But the medium sized one is enough to cook for large groups of people already. Built to have a high capacity, this smoker allows for multiple cooking at the same time.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.
This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
At Grills Forever, we work hard to bring you the best product reviews possible through an extensive online research process. We go through countless online reviews and browse through different brands, both known and unknown. We then go through their features and the value they can provide to the users. We shortlist the top products to do physical testing and then come up with a review. We do this on a regular basis to keep our list up-to-date.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.

The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.


Our reviewers spent 12 hours testing a top-selling, budget-friendly pellet grill. To get the most comprehensive feedback possible, we had our testers take this grill for a spin and had them consider its most important features — from how much it can cook at a time to how easy it is to travel with. We've outlined the key pointers here so that you, too, know what to look for when shopping.
This grill produces fall off the bone ribs. I've also cooked a brisket to perfection. My only issue is that I have to clean it after every use. If it isn't cleaned properly (I remove all of the grates and use a shop vac to suction all ashes and unburned pellets) the pellets will back up and when they finally push through, you will have a huge flare up that will potentially burn whatever you are cooking as well as take the paint off the grill itself. Also, I find it works better if you set the dial to OFF and then back to whatever temperature you want. Other than those few quirks, I love this grill. I did find a larger Pit Boss after I bought this one, but it was about $150 more.

You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
Not only do cheap grills not hold up as well, but there are additional benefits to better steel and construction, too. Construction quality matters in wood pellet grills, no matter the price. Take the video below where we compare Grilla Grill’s double wall insulation to Camp Chef, which is not a cheap grill by any stretch. This video shows how well the Grilla Grills pellet grill is able to retain heat, keep the cool out, and use less fuel than many other wood pellet grills. Now imagine how much difference this would make compared to a bargain basement pellet grill from a big box store!
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
This is a great smoker for beginners who are willing to take the time to understand how pellet smokers work. You can follow the instructions in the video provided on the manufacturer’s website to see how to put it together. It is also great for people who have been pellet smoking for years. It has a huge cooking surface, which is perfect for entertaining large groups of friends.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
3-DFT12 Size: 12" Features: -You can now take the guesswork out of outdoor grilling and concentrate more on the beauty of the grea...t outdoors. -Allow yourself to effortlessly monitor and regulate the temperature of your grill with the Camp Chef Thermometer. Product Type: -Thermometer. Finish: -Silver. Tool Head Material: -Other. Number of Items Included: -1. Dimensions: Overall Product Weight: -1 Pounds. Size 6" - Overall Height - Top to Bottom: -6 Inches. Size 6" - Overall Width - Side to Side: -2 Inches. Size 6" - Overall Depth - Front to Back: -2 Inches. Size 12" - Overall Height - Top to Bottom: -12 Inches. Size 12" - Overall Width - Side to Side: -2 Inches. Size 12" - Overall Depth - Front to Back: -2 Inches.Package Quantity : 1 read more

Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:


One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.

This is the most important aspect you should look into when buying a new pellet grill. You always hear people saying that a product will cost more money if it’s built with better quality materials and that is absolutely true when it comes to pellet grills. Let’s start with the basics – the most common material that is used when producing a pellet grill is steel. There are many different types of steel from high-grade stainless steel to lower grades that aren’t as sturdy. Cheap pellet grills will be constructed of a decent grade of steel when creating the outer appearance so that it’s sharp to look at. However, the inner parts of the grill are made out of lower-grade metals. Do you see the problem here? Even though the grill may look aesthetically pleasing from the outside, these nice looks won’t make up for thelow-quality materials that are used inside. This can quickly lead to the inner components of the grill deteriorating and in need of replacements. This ultimately results in you spending additional money to replace these parts once they are no longer functional.


With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?


“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
×