Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..
This company sucks.  I purchased a low end Traeger and got three months use out of it...  Waste of $350 at costco.   On the positive side I liked the way food tasted after the smoking process so about a year later I purchased a high end Select Pro Grill for around $1,000.  Almost immediately after the warranty expired the thing caught on fire and almost burned my house down.  For some reason the pellet furnace overflowed and filled the bottom of the unit with a mound of burning pellets.  The accumulated grease caught fire and up she went.   I caught it relatively quickly but had to use a hose to put it out.  The unit sopped working and the worst part is I was willing to pay to have it repaired.  I found a local repair shop that was a "premier" partner with Traeger and was told we cannot fix the unit without Traeger's approval.  I wrote to traeger and they ignored my email...    That is it for this company - they have lost my business and I advise you to buy one of their competitors products
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
So if you want more of a smoke profile, cook at longer and lower temps in your pellet pit. I have found that is the best way to get a more distinct smoke profile in your food. Cook at 180–190 for the first several hours. That probably has the biggest impact. Next, make sure you are using a good, quality hardwood pellet. I can tell you that you will notice a very large difference in the flavor profile between say a Traeger pellet vs. say one of Candy’s [BBQers Delight pellets]. — Read more on PelletSmoking.com
I’ve been grilling and smoking for many years and throughout all those years I have burned through many expensive grills. Four years before I purchased the 640 I got on the pellet smoker wagon and started my research. Finally when my daughter was getting married she ask me to cook for the wedding and gave me the perfect excuse to finally get a smoker I wanted. So getting back to the research and after 3 months of comparing I settled on the YS640. I wanted a grill, at my age, to be able to pass down to one of my kids. It was big investment but like I’ve learned in life, you get what you pay for “most” of the time. I have had this grill now, September 2018, will be 4years now. I have no regrets and would do it again. I’ve had some minor corrosion issues and after an email was promptly sent the matching paint to clean it up. I spent the time to do it right and today, a month later, today my grill looks brand new. Honestly nothing like this can be left to take care of itself. Maintenance like anything else is required. But I know this will most likely be my last grill. Thank for a great product and great follow up service. Smoke Shack.....

Bought my Texas Elite 34 Traeger pellet grill last summer at Oshkosh Fly-in. Received it and assembled it with no issues. Began using it and discovered it will not make temperatures above 375 deg F. Most of the Traeger recipes need 400+ deg, so this wouldn't work. Called Traeger. They started sending me replacement parts, first the combustion air fan, then the auger motor, then a digital temp controller. None of these new parts had any effect on the problem. I have probably called Traeger 10 times, finally getting a hold of a second level supervisor named Jessie. He decided to send me a whole burner module; pellet hopper, auger tube, burner bowl, fan, controller... everything in one assembly. I installed it and no improvement. I did a time vs temp test for them at their request. They finally agreed it wasn't working properly.
If you have faced or currently face the problem with common things like pellet feed jamming or wear and tear of your smoker, then replacing the exact component will solve your problem. Thus, without changing your whole smoker you can continue with some $40 – $50 changes. It might seem complicated for you if you face a problem with your digital control system. Adding the element of professional knowledge will help tremendously. Solving problem with $150 is much better than spending $500, right?
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.
What are your thoughts about the Kalamazoo hybrid grills? From what I’ve found online, you have the choice of gas, charcoal and wood for cooking or combinations of all. I have no first hand experience with Kalamazoo but it seems very versatile? At the moment after a month of researching, I’m leaning towards a Mac/Yoder or a Webber spirit & egg or a Memphis….so in other words, I’m no closer to a decision than when I started. I currently have a 9 yr old treager that won’t break, seriously, I’ve only repainted once with rustolium….dang thing won’t break so I can get a new toy. I sear in a skillet in the kitchen. My treager has the smoke/med/high switch and I want more control, I’ve maxed what I can do and it’s a challenge in cold weather and wind but it was a great start when they were made to last, more than got my money’s worth. I cook at all levels from smoking to grilling. I do love pellets and don’t want an egg but enjoy the food as much as the process of preparing it. Ok probably to much info but money aside, will you list your recommendations of what you think is best for me?
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.
When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
This 4-quart Classic-style 10 Inch Dutch features a beautiful white tail deer etching on the lid, three legs, a handled lid and ba...le. The raised lip around the lid is excellent for cooking with charcoal briquettes or wood. Seasoned and ready to cook.Total Weight = 13 lbs.Depth: 3 1/4 InchCapacity: 4 QT.ID = 10 InchOD = 10.25 InchModel No: SDO10UPC Code: 033246208060 read more
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazon https://tinyurl.com/amazingribs
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised. 

Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.

SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase


For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.


Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase.

When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
At Grills Forever, we work hard to bring you the best product reviews possible through an extensive online research process. We go through countless online reviews and browse through different brands, both known and unknown. We then go through their features and the value they can provide to the users. We shortlist the top products to do physical testing and then come up with a review. We do this on a regular basis to keep our list up-to-date.
Ninth spot to make it to our compilation of the pellet grill review is the Louisiana pellet grill. It has 2 cooking levels and a total 1061 square inch cooking surface. The Louisiana pellet grill has got porcelain cast iron main grids and porcelain steel removable upper cooking grid. It also has a digital controller centre. This grill weighs around 173 pounds and is made with high quality material that is going to last you a life!
Bigger heavier hotter: own a world class BBQ Bigger heavier hotter: own a world class BBQ in your own backyard. The LG900 presents the same game-changing features as the LG700 integrated with a larger cooking surface. Perfect for larger families and social gatherings the LG900 bears an easy to clean 913 sq. in. cast iron cooking grid. Elevate ...  More + Product Details Close
Fans of gadgets – More expensive models come with very interesting features. You can download app for your phone or tablet (iOS and Android). Then you can use Wi-Fi to connect with your pellet grill. It allows you to monitor the temperature inside the grill while away from it. Some of the grills even make it possible to check the internal temperature of the meat.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
Yoder YS 640 is built out of durable materials. Unfortunately, this means that it is heavier than some other units. It weighs 325 lbs, nearly twice as much as the Traeger Texas Elite 34. The main body is built out of 10 gauge metal. It will take more time to reach the highest temperature, however the smoker will hold the heat in far better than some other cookers.
Compared to the Traeger Pro and the other smokers we’ve reviewed, there’s not much not to like about this bad boy. It’s significantly cheaper, packs ample cooking space, and a good, consistent temperature controller. At 173 lbs, it is quite heavy, and not at all portable like the Davy Crocket, and we’d love to see it come with more precise temperature control, and maybe even WiFi in the future. But for the price, it’s a beast of smoker that is almost as good as the Traeger.
2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.

I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.

A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs. 

The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
Looking for a pellet grill to do all sorts of cooking with. I am between a Rec Tec, Camp Chef Woodwind, Gorilla and Yoder. Steaks, burgers, chicken, ribs, brisket, vegetables, etc. All in one. And want to have the option to sear meat, veggies as well. Ive seen so many different reviews my head is spinning. My budget is $700-$1,000 but willing to go up if necessary. I hear some can sear, some take too long to heat up, some dont hold the temp consistently. I am a low maintenance so ease of use important. Does not have to be portable.
It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
Kevin: I have a gas smoker but would like a wood pellet smoker. I’m looking at Traeger Lil Tex (due to price) but I read about Blazn Grill Works, Grand Slam, made in USA, stainless steel grates and a control unit that is very good. Cost about $1195, can’t find dealers so called and talked with the owner. What I read on web site sounds good. He claims on his short video that his auger is the best and doesn’t put torque on the drive due to the design. Any thoughts on this unit? Any advice would be appreciated. Still looking at the Yoder YS640 as price is very similar.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
The Redwood Portable Fire Pit is an upgrade from the original Gas Fire Ring. A taller, more sturdy base stand, safety ring/carry h...andle, matchless ignition, and a laundry list of other features, the Redwood is the next step in portable propane fire pits. Camp Chef Gas Fire Pits are allowed for use in most fire ban restrictions, check with the local Ranger Station before use. read more

Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
Certain statements in this press release, including statements regarding the expected future financial performance of Camp Chef and the impact of that performance on Vista Outdoor, constitute forward-looking statements as defined in the Private Securities Litigation Reform Act of 1995. The words 'believe', 'expect', 'anticipate', 'intend', 'aim', 'should' and similar expressions are intended to identify such forward-looking statements. All such forward-looking statements involve estimates and assumptions and are subject to a number of risks and uncertainties, many of which are beyond Vista Outdoor's control, which could cause actual results to differ materially from the expectations described in the forward-looking statements. Among those risks and uncertainties are: assumptions regarding demand for Camp Chef's products; the risk that the anticipated benefits and cost savings from the transaction may not be fully realized or may take longer than expected to realize; the ability of Vista Outdoor to retain and hire key personnel and maintain relationships with customers, suppliers and other business partners of Camp Chef; costs or difficulties related to the integration of the business following completion of the transaction; and changes in the business, industry or economic conditions or competitive environment. Vista Outdoor undertakes no obligation to update any forward-looking statements. For further information on factors that could impact Vista Outdoor, and the statements contained herein, please refer to Vista Outdoor's most recent Annual Report on Form 10-K and any subsequent quarterly reports on Form 10-Q and current reports on Form 8-K filed with the U.S. Securities and Exchange Commission.
But if you like the idea of a wood pellet grill, one of the oldest names in wood pellet grilling is Traeger, which developed some of the first units to use this technique three decades ago. Having that name recognition gives Traeger a leg up versus some of its competitors. And for the most part, Traeger’s grills live up to what consumers expect from this established brand, providing good design and longevity. They don’t typically match up with the higher end models currently on the market in terms of precise cooking temperatures, but Traeger is a nice mid-range product with several price points available.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.

How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.


I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.

Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
With Davy Crockett’s Wi-Fi feature you will have more time to interact with your friends and family. Download the GMG’s app to your phone and you will be able to turn the cooker on and off, monitor and control internal meat temperature, and even receive system malfunction or low fuel warning. In addition, you can even add time and temperature instructions for your favorite recipes. For example, the grill can cook at 225°F until the internal meat temperature is 110°F. Then, the heat can be turned up to 500°F for browning until the temperature of the meat is 135°F. Lastly, the temperature can be dropped to 140°F to keep the meat warm.
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
What makes this smoker unique, though, is the sear box. It runs on propane, and it gets VERY hot, VERY fast. You can easily sear meats on it, and many use the "reverse sear" method, which means to sear meats AFTER smoking them. Additionally, the sear box can be used as a small propane grill; we use it all the time for things like hot dogs and sausages.

Camp Chef Smoke ProDLX Pellet Grill:Stainless steel lid and handleElectronic auto-start ignitionDual LED temperature readout: inte...rnal cooking temps and internal food tempsEasily choose your smoke settings or desired temperatureAutomatic auger dispenses pellets as needed for improved smoker efficiencyStainless steel probe measures internal food temperatureBuilt in sensor gauge reads cooking temperatureIncluded warming rack provides additional space to cook your favorite foodsClean-out ash can makes clean up simpleLarge capacity pellet hopper means less filling, more smokingNew hopper clean out makes changing pellet flavors easier than everIncludes recipe ideas in manual SpecificationsGrilling Area Dimensions: 19.5" x 22"Smoking/Warming Rack Dimensions: 6" x 24"Total Rack Surface Area: 560 sq inHopper Capacity: 18 lbs of pelletsCooking Height: 32.5"Overall weight: 127 lbs read more
Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.

Thanks for the great information and the research you did. I am a retail store owner in Boise, Idaho area and we sell a pellet grill smoker in our store. I would like to encourage to look at the Sawtooth Pellet Grill. It is made local here and is American Made. It is an excellent grill for the price with an awesome company backing it. You can find their website at sawtoothpelletgrills.com. Again thanks for the information and if you do another publication regarding pellet grills, I would love to see what your opinion of the Sawtooth would be 🙂

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
It’s got built in manual controls, but there’s also the option to download an app to your phone so you can control your smoker through your wifi! Honestly, this really impressed me, and I don’t know why other manufacturers aren’t all over this. Apparently there’s a cloud based app coming out soon so you can control your grill anywhere you can get internet, so you could be sitting at your kids football game whilst checking the status of your post-victory feast! The controls are also fully programmable, so you could for example set it to smoke for 5 hours and then cook for 2, finishing just as you pull up onto your drive.
While the exterior is certainly whimsical, this smoker is serious business, with a proprietary Digital Pro Controller that maintains even cooking temperature, just like an oven. Dual meat probes let you monitor the pork and the chicken at the same time, and 425 square inches of grilling space means you can easily feed a crowd. The 11.5-pound hopper holds plenty of pellets, so you won’t need to refill for many hours.
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
We all know about Davy Crockett and Daniel Boone, but Traeger is the true pioneer of pellet smoking. This company introduced the first pellet smokers, and it remains the best-known brand, although competition is growing. There's nothing fancy here. Instead of a touch-pad controller, Traeger employs an older-style digital dial controller. No WiFi or meat probes; just no-frills schmokin' from the industry leader.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.

The Traeger Pellet grill can accommodate temperatures from 180 degrees to 375 degrees, and high. It has a state of the art digital temperature control system that not only monitors the temperature to keep it consistent and even, but also regulates the pellets the auger feeds to the fire according to that temperature. This is truly a grill worthy of a place in our pellet grill review.
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.
If the metal is too thick, you will also use a lot of pellets. The walls of a thick-bodied smoker act as a “heat sink”. Heat is taken away from the cooking area and stored in the walls of the cooker. So, it will take a lot of pellets to get the cooking area up to the desired temperature. While thick walls are desirable for some types of cookers, they are not required in pellet smokers.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
Pellet grills have a couple of very distinct advantages and disadvantages. The best can hold a constant temperature more or less indefinitely, provide even smoke at low temps, cook w/o smoke at high temps, make it possible to evenly cook several different meats and do a good job at two zone cooking. The Yoder excels at these. It is built like a tank, easy to use and I love it. One drawback for some pellet grills is the inability to reach high temps and sear. With the GrillGrates I have reached almost 600F and can sear with the best of them. Drawbacks. Well, it is a bit tricky to clean, but I guess I am keeping it cleaner than I did my previous grills!

The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.
I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.

The higher the temperature range goes, the more your pellet smoker can do. For example, a pellet smoker with a temperature range of 500°F- 700°F is hot enough to sear food and even bake a pizza. Consider getting a good thermometer or even a meat probe so you could have an accurate reading and make sure you are cooking your food at the right temperature.
×